2008 Toyota Prius problems, complaints & recalls

2008 Toyota Prius recalls (3)

• Recall 12V537000Nov 14, 2012669,705 vehicles
  STEERING · STEERING:GEAR BOX:SHAFT SECTOR

  Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

  Risk: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

  Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

• Recall 12V536000Nov 14, 2012350,662 vehicles
  ENGINE AND ENGINE COOLING · HYBRID PROPULSION SYSTEM: INVERTER

  Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

  Risk: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

  Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

• Recall 10V036000Feb 3, 2010153,418 vehicles
  EQUIPMENT:OTHER:LABELS

  Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.

  Risk: A driver may overload a vehicle which may increase the risk of a crash.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast toyota at 1-800-301-6859.

NHTSA defect investigations

• DP22005Opened Jan 27, 2023Closed Aug 7, 2023led to recall 22V063000

  Pedestrian alert sounds

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc…

• DP13001Opened Feb 21, 2013Closed Apr 8, 2020

  Intermediate Steering Shaft Separation

  The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and…

Recent 2008 Toyota Prius complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed May 12, 2026CAEngine

   Water pump failed after replacement in 2013 with 30k miles, car had only 93k miles when failed again in 2016. The potentiometer part failed, there is corrosion in the part. Was in freeway when it failed. I have reported this to different representatives. I was charged more 1.5k for a replacement of a faulty part that should last more than 50k miles.

   NHTSA complaint #11737450 · source
2. Filed Apr 22, 2026ORAirbags

   the cruise control was inop, technician said it was a clockspring failure, replaced the clockspring with a new part from walmart, then at times, the airbag failure light would come on, paid a technician to replace the replacement clockspring with an new one and the failure stopped, walmart is selling a part that could result in death

   NHTSA complaint #11733033 · source
3. Filed Mar 18, 2026CABrakes

   2008 Toyota Prius gen2 with 139k miles. ABS, Brake, parking brake, and Traction Control lights all illuminated while driving the other day. Potential is losing all electronically assisted braking function in the car. Problem has been confirmed by local independent service center. Independent service center pulled codes: C1256 Accumulator low pressure C1378 Capacitor Communication Malfunction C1391 Abnormal leak of ACC pressure all consistent with ABS accumulator failure.…

   NHTSA complaint #11725225 · source
4. Filed Feb 1, 2026WVBrakes

   Brake pedal became hard and vehicle was difficult to stop. ABS warning light appeared on dashboard. This is a problem that Toyota has addressed previously by extending the warranty period to 10 Years/150,000 miles. My vehicle has 122,000 miles on it but the 10 year extended warranty has expired. I took the vehicle to a local repair shop and they confirmed that there was a problem with the brake actuator assembly. Now, Toyota says it would cost over $3000 to remove and…

   NHTSA complaint #11714800 · source
5. Filed Dec 20, 2025NYOther / Unknown

   In 2025 I decided to clean the hybrid battery fan. I removed the side panels and found that the fan to battery duct had never been installed. I am the original owner and no one had ever removed the inside panels or had reason to remove the duct. This has likely resulted in the overheated battery which now needs replacing even though I have only 161,000 miles on this car which I have always maintained without fail regarding oil changes and other maintenance tasks.

   NHTSA complaint #11706320 · source
6. Filed Oct 1, 2025CAElectrical System

   In the cars digital instrument cluster have problem on the same model many of cars because I know many of friends that have same model car and I get problem so I go to the mechanic and the mechanic says it is a manufacturing problem on that same model have same problem I repair it twice and now it again appears it's also a safety concern because the problem is the light is completely go out completely blank so we are not able to see the vehicle speed vehicles fuel gas and…

   NHTSA complaint #11690871 · source
7. Filed Sep 26, 2025MOBrakes

   The ABS brake booster/accumulator is going out and this has been a known issue with Toyota for years. Mine was purchased used a few years ago and had no issues until recently, as the pump is running more frequently.

   NHTSA complaint #11689871 · source
8. Filed Aug 31, 2025MIBody & StructureElectrical SystemOther / Unknown

   Trunk lock will not unlock or allow opening, back latch malfunctions, when car battery dies or car looses power《• you cannot open the trunk and access emergency tools/equipment and battery to jump car. •》You have to access by climbing through the front of the car if you are able-bodied too. There is no opening handle from the inside of the trunk to be let out, scariest and one of the most important major safety concerns, theres no emergency exit from inside vehicle.…

   NHTSA complaint #11684149 · source

Compare the 2008 Toyota Prius with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology