2008 Toyota Highlander problems, complaints & recalls

2008 Toyota Highlander recalls (9)

• Recall 16V396000Jun 2, 20167,749 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

  Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

  Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

• Recall 15V689000Oct 22, 20151,814,284 vehicles
  VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

  Risk: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

  Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

• Recall 14V743000Nov 19, 20143,233 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

  Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

  Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

• Recall 14V168000Apr 9, 20141,486,413 vehicles
  AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

  Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.

  Risk: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.

  Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.

• Recall 12V491000Oct 10, 20122,519,424 vehicles
  VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

  Risk: If the switch overheats, it may melt, possibly resulting in a fire.

  Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

• Recall 11V245000Apr 21, 2011307,848 vehicles
  AIR BAGS · AIR BAGS:SIDE/WINDOW

  Toyota is recalling certain model year 2008 highlander, highlander hybrid, and model year 2007-2008 rav4 vehicles. In the curtain shield airbag (csa) system, there are two sensors in the airbag sensor assembly which are designed to detect vehicle roll angle. If one of these sensors malfunctions, the airbag warning light (malfunction indicator light: mil) will illuminate and the roll detection system will be suspended; however, the airbag csa remains available in the event of a side crash. If both sensors fail nearly simultaneously after initial airbag system check, the csa and the seat belt pretensioner could be inadvertently activated.

  Risk: Inadvertent activation of the csa and/or the seat belt pretensioner can cause injury to a vehicle occupant.

  Remedy: Toyota will replace the airbag sensor assembly with a new one containing improved roll rate sensors, free of charge. Toyota intends to send an interim owner notification to owners early to mid-may, 2011 when sufficient parts and remedy becomes available. Owners may contact toyota at 1-800-331-4331.

• Recall 10V036000Feb 3, 2010153,418 vehicles
  EQUIPMENT:OTHER:LABELS

  Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.

  Risk: A driver may overload a vehicle which may increase the risk of a crash.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast toyota at 1-800-301-6859.

• Recall 10V035000Feb 3, 2010271,417 vehicles
  EQUIPMENT:OTHER:LABELS

  Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.

  Risk: This does not meet the standard requirements.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on may 27, 2010. Owners may contact gulf states toyota at 713-580-3300.

• Recall 10V023000Jan 27, 20101,126,915 vehicles
  VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

  Toyota is recalling certain model year 2008-2010 highlander, model year 2009-2010 corolla, venza and matrix passenger vehicles. The accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat. This recall is an expansion of a campaign of 3.8 million other toyota vehicles announced in 2009 for the same issue (see 09v-388).

  Risk: A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.

  Remedy: Toyota will modify or replace the accelerator pedals on the subject vehicles. Floor surface modifications are also being considered and will be included for any model for which it is deemed appropriate. Initially, dealers will be instructed on how to reshape the accelerator pedal for the repair. As replacement parts with the same shape as the modified pedal become available, they will be made available to the dealers for the repair. Customers who have had the pedal reshape remedy completed will have the opportunity to receive a new pedal if they desire, after replacement pedals become available. In addition, toyota will replace any toyota all-weather floor mat in a subject vehicle with a newly designed mat, free of charge. For those customers who have the previous design all-weather floor mat but do not need or want the newly designed all-weather floor mat, toyota will recover the previous design all-weather floor mat and reimburse its price. The safety recall began march 30, 2010. Owners may contact toyota at 1-800-331-4331.

NHTSA defect investigations

• EA18006Opened Nov 16, 2018Closed Apr 2, 2024

  Steering Column Separation

  On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005).  The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, …

• PE18005Opened May 4, 2018Closed Nov 20, 2018

  Upper Steering Column Separation

  On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submit…

Recent 2008 Toyota Highlander complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Sep 21, 2026264,000 miCAElectrical System

   Odometer Fraud. The contact purchased a 2008 Toyota Highlander. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. The contact stated that at the time of purchase the mileage was 106,000. After obtaining a Carfax report, the contact became aware that the mileage listed was 264,000.

   NHTSA complaint #11765753 · source
2. Filed Mar 6, 2026100,000 miNYFire1 injuredTowedEngine

   The contact owned a 2008 Toyota Highlander. The contact stated that while driving at approximately 20 MPH, an abnormal, booming sound was emitted from the vehicle as heavy, black smoke entered her vehicle. Due to the smoke, the contact's vision became obstructed, and the contact immediately shifted into park and jumped out of her vehicle for safety. It was unknown if there were any warning lights. As a result, the contact injured her right hip and strained her vocal cords.…

   NHTSA complaint #11722415 · source
3. Filed Sep 25, 2025COBrakes

   There was no incident. When the brake malfunction screen displayed, i drove the vehicle to the nearest toyota dealer in pueblo, colorado. I received the attached service message and picking ticket; 17june2025. It also needs new brake pads, rotor adjustment, and 5 new tires. Total~$6000. Way too pricy! I paid for the diagnostic test, and drove home carefully! The vehicle has been sitting in my carport since, and i am walking the city limits for all purposes. The 12v battery…

   NHTSA complaint #11689649 · source
4. Filed Sep 12, 2025PABrakesElectrical System

   My 2008 Toyota Highlander Hybrid is having severe issues with the ABS system. Toyota is reporting that it needs an ABS actuator and ABS pump replacements. These were a part of Toyota's previous Customer Support Program, but the program expired before I owned the vehicle. That is EXTREMELY dangerous and the issue with the ABS system should be considered a Safety Recall that is ALWAYS available to Toyota customers to rectify and paid for by Toyota. It is a BRAKING ISSUE. It is…

   NHTSA complaint #11686896 · source
5. Filed Aug 17, 2025CAElectrical System

   The Intelligent power module failed on the vehicle. I read this is common for my vehicle however there is no recall matching my VIN. Vehicle was purchased out of state one year ago. We took the vehicle to a Toyota dealership who suggested I inquire about the issue because it’s possible this VIN should have been included.

   NHTSA complaint #11681187 · source
6. Filed Aug 14, 2025271,890 miCAElectrical System

   Odometer Fraud. The contact purchased a 2008 Toyota Highlander. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 123,399, and at the time of registration, it was discovered that the mileage was 271,890.

   NHTSA complaint #11680713 · source
7. Filed Jul 17, 2025PABrakes

   Good Afternoon, The brake actuator and booster pump failed on my 2008 Toyota Highlander Hybrid. ABS, Brake, and VSC warning lights came on, and the brakes became weak and unsafe. A repair shop confirmed the issue with codes C1252, C1256, and C1391. I tried to fix it at a local shop last year, but the problem came back. It seems this repair can only be fully done at a Toyota dealer due to software requirements. However, the dealer repair cost is very high. I cannot afford the…

   NHTSA complaint #11674307 · source
8. Filed Nov 26, 2024CABrakes

   Brake actuator failure. Have to manually brake, stopping distance significantly increased. 3,145$ to replace at Toyota dealership.

   NHTSA complaint #11627605 · source

Compare the 2008 Toyota Highlander with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology