2017 Toyota Prius problems, complaints & recalls

2017 Toyota Prius recalls (3)

• Recall 18V579000Sep 5, 2018192,347 vehicles
  ELECTRICAL SYSTEM:WIRING

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2018 Toyota Prius vehicles. A portion of the engine wire harness connected to the hybrid Power Control Unit (PCU), could contact the cover at this connection and wear, causing an electrical short circuit.

  Risk: An electrical short can increase the risk of a fire.

  Remedy: Toyota will notify owners, and dealers will inspect the engine wire harness assembly and replace it if damage is found. A protective sleeve or protective tape will be included to prevent any future damage. These repairs will be performed free of charge. The recall began October 30, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0T.

• Recall 17V295000May 2, 2017409 vehicles
  TIRES:TEMPORARY/EMERGENCY SPARE TIRE

  Gulf States Toyota, Inc. (Gulf States) is recalling certain 2017 4Runner , 86, Avalon, Camry, Camry Hybrid, Corolla, Corolla iM, Highlander, Highlander Hybrid, Prius, Prius C, RAV4, RAV4 Hybrid, Sienna and Yaris vehicles. The spare tire air pressure was not adjusted to the proper pressure as stated on the Tire Pressure Label.

  Risk: A spare tire that is not inflated to the proper value may not perform as intended, increasing the risk of a crash.

  Remedy: Gulf States will notify owners, and dealers will inspect the spare tires, adjusting their pressure as necessary, free of charge. The recall began June 15, 2017. Owners may contact Gulf States customer service at 1-800-444-1074. Toyota's number for this recall is 17R2.

• Recall 16V741000Oct 14, 201691,585 vehicles
  PARKING BRAKE

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016-2017 Prius vehicles manufactured August 6, 2015, to October 3, 2016. The affected vehicles are equipped with a foot-operated parking brake system that has a parking brake cable that may disengage.

  Risk: If the parking brake cable disengages from the mechanism and the transmission is left in a gear other than 'Park' while the ignition is on and the driver leaves the vehicle, the vehicle may roll unexpectedly, increasing the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will install a clip at the parking brake cable end to prevent the cable from disengaging, free of charge. The recall began November 10, 2016. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is G01.

NHTSA defect investigations

• DP22005Opened Jan 27, 2023Closed Aug 7, 2023led to recall 22V063000

  Pedestrian alert sounds

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc…

Recent 2017 Toyota Prius complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed May 19, 2026PAEngineFuel, Hybrid & EV Propulsion

   The catalytic converter heat exchanger failed internally, causing coolant to leak into the exhaust system. Symptoms included white smoke from exhaust and coolant loss with no visible ground leak. This is a documented factory defect per Toyota Technical Service Bulletin T-SB-0135-19 affecting 2016-2019 Prius models. Toyota has denied warranty coverage despite the vehicle was originally bought & spent its entire prior operational life registered in New York, a state covered…

   NHTSA complaint #11738755 · source
2. Filed Dec 19, 2025225,810 miFLElectrical System

   Odometer Fraud. The contact purchased a 2017 Toyota Prius. It was discovered when the contact listed the vehicle for sale that there was a mileage discrepancy. The vehicle was as a private sale. At the time of the purchase, the mileage was 126,611. The potential purchaser provided a CARFAX report that recorded the mileage on 11/6/2024 at 225,810.

   NHTSA complaint #11706080 · source
3. Filed Jul 18, 2025AZFuel, Hybrid & EV Propulsion

   During hot temperatures and after coming to a full stop, the car stalls/hesitates significantly (5-6seconds) when pushing the gas pedal. The car eventually proceeds but the issue reoccurs. It can only be intermittently reproduced and no codes are shown on the car dashboard. Mechanics are unable to identify the source of the issue so it cannot be resolved.

   NHTSA complaint #11674665 · source
4. Filed Feb 27, 202581,700 miILEngine

   The contact owns a 2017 Toyota Prius. The contact stated that while driving approximately 25-30 MPH, the vents were blowing out cold air. The check engine warning light was illuminated. The contact was adding coolant to the coolant reservoir every three to four days. The vehicle was taken to the local dealer, where it was diagnosed and determined that the coolant was leaking into the exhaust pipe. The dealer recommended that the exhaust system front pipe be replaced. The…

   NHTSA complaint #11645348 · source
5. Filed Nov 27, 202468,000 miCATowedTransmission & Drivetrain

   The contact owns a 2017 Toyota Prius. The contact stated while the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed. The accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The contact stated that the vehicle stalled and jerked. The vehicle was driven to the residence. The contact stated that the battery indicator did not look as if the battery was charging. The contact stated that the vehicle was…

   NHTSA complaint #11627707 · source
6. Filed Nov 21, 2024CAEngineFuel, Hybrid & EV Propulsion

   Dear NHTSA, I am seeking assistance and compensation for ongoing warranty and repair issues with my Toyota Prius. Key Incident Timeline: •March 21, 2024: Dashboard message “Grille Shutter Inoperable” •March 25, 2024: Toyota of Glendale visit •Charged $220 for diagnostics •Refused to honor service bulletin •Vehicle mileage: 149,217 Customer Service Interactions: •April 9, 2024: •Contacted Toyota customer service •Confirmed CA emissions coverage to 150,000 miles •Discovered…

   NHTSA complaint #11626715 · source
7. Filed Jul 30, 2024MOOther / Unknown

   While driving the speed limit of 70mph on a major highway, the sunroof on my 2017 Toyota Prius exploded. There was no warning of any kind: no other traffic nearby so no rock or debris from another vehicle; no overpass or bridge so nothing from above; it was a mild sunny day of 76 degrees so not a weather factor; and by the angle of the glass that remains being in an outward position rather than inward, reveals to me that it was from inside out, not from outside in as if it…

   NHTSA complaint #11605347 · source
8. Filed Jul 22, 2024COEngine

   Coolant leaking into exhaust And engine also vehicle suddenly stops for no reason now engine is completely broken due to the coolant going into the motor oil

   NHTSA complaint #11603676 · source

Compare the 2017 Toyota Prius with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology