2011 Toyota Prius problems, complaints & recalls

2011 Toyota Prius recalls (6)

• Recall 18V684000Oct 4, 2018807,329 vehicles
  HYBRID PROPULSION SYSTEM

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.

  Risk: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.

• Recall 16V487000Jun 30, 2016482,002 vehicles
  AIR BAGS:SIDE/WINDOW

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.

  Risk: If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.

  Remedy: Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.

• Recall 16V396000Jun 2, 20167,749 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

  Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

  Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

• Recall 14V743000Nov 19, 20143,233 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

  Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

  Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

• Recall 14V053000Feb 12, 2014698,457 vehicles
  ELECTRICAL SYSTEM:SOFTWARE · HYBRID PROPULSION SYSTEM: INVERTER

  Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.

  Risk: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.

  Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.

• Recall 13V014000Jan 16, 20133,235 vehicles
  AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE · SEATS

  Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

  Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

  Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

NHTSA defect investigations

• DP23005Opened Nov 22, 2023Open

  Brake Actuator Valve Wear

  The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additi…

• DP22005Opened Jan 27, 2023Closed Aug 7, 2023led to recall 22V063000

  Pedestrian alert sounds

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc…

• DP19004Opened Sep 30, 2019Closed Jan 21, 2021

  Brake Actuator Valve Wear

  On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s requ…

NHTSA 5-Star safety ratings

Recent 2011 Toyota Prius complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Oct 1, 2026TXBrakes

   I was driving on the highway when my 2011 Toyota Prius started beeping repeatedly, and as I approached the red light, my brakes were not operational. My car completely passed through the red light, narrowly missing what could have been a fatal accident for me and others on the road. I had to navigate to the furthest right lane, almost getting hit by others due to my speed and inability to stop my car. I was going at 50 mph through the intersection, and had to gradually lower…

   NHTSA complaint #11768253 · source
2. Filed Sep 30, 2026CABrakes

   2011 Toyota Prius with approximately 134,000 miles. The brake actuator/master cylinder has been diagnosed as malfunctioning and failing to maintain hydraulic pressure. The brake booster pump initially began cycling approximately every 10 seconds while the vehicle was in READY mode, stationary, and without the brake pedal being applied. The cycling subsequently increased to approximately every 3 seconds. The affected components remain installed and are available for…

   NHTSA complaint #11768168 · source
3. Filed Sep 22, 2026NJEngine

   Coolant leak into the engine, confirmed by the Toyota servicing center. This may be a common problem with the Toyota Prius, causing early engine failure from a design defect.

   NHTSA complaint #11766266 · source
4. Filed Sep 14, 2026VACrashBrakes

   I am filing this complaint to report an active, severe safety defect involving a sudden, un-warned loss of power braking assist due to a failing factory brake actuator/booster pump assembly. My vehicle is exhibiting the exact internal hydraulic seal failure, pressure drop, and audible hissing/sipping sound outlined in Toyota's prior technical service bulletins. Because the onboard ECU computer only triggers warning lights once a complete, catastrophic failure threshold is…

   NHTSA complaint #11764198 · source
5. Filed Aug 10, 2026IABrakes

   Vehicle Information: 2011 Toyota Prius, 144,000 miles. Component: Hydraulic Service Brakes, Electronic Stability Control, Anti-lock Braking System. Description of Incident: While driving at normal speeds, the vehicle suddenly experienced a severe reduction in braking capability. The dashboard simultaneously illuminated the Brake Warning Light, ABS Light, and Slip/Traction Control Indicator Light. The brake pedal immediately became soft, spongy, and squishy, requiring…

   NHTSA complaint #11756097 · source
6. Filed Jul 26, 2026TXBrakes

   Every time I'd press the brakes there'd be an audible "click" noise and then when taking my foot off the brake it'd sound like a manual tire pump being pressed... kind of like air filling / hydraulic sound. This worried me (I don't mess around with brakes). One other thing that would happen is if I pressed the brake hard enough, the automatic braking system would kick in. The Toyota dealership claimed they couldn't hear anything and there were no warning lights so I took it…

   NHTSA complaint #11752939 · source
7. Filed Jun 26, 2026CABrakes

   Vehicle Information: Year: 2011 Make: Toyota Model: Prius Mileage at Failure: 58,769 miles Date of First Use: February 20, 2012 Complaint Description: As I was driving on the freeway, my 2011 Toyota Prius brakelights all came on. I pulled off, had it towed to nearest mechanic, who diagnosed a failure involving the brake booster, brake actuator, and ABS system at only 58,769 miles. The vehicle was diagnosed with Diagnostic Trouble Code C1391 (Abnormal Leak of Accumulator…

   NHTSA complaint #11746722 · source
8. Filed Jun 18, 2026NCBrakes

   Shortly after purchasing used last year I had my brake, traction control, ABS, & TPMS lights come on when stopping at a stop light all at once. I went and had it scanned and no codes showed up. I hear a buzzing from the brake actuator/ brake pump every 15 seconds. This all has been going on for almost a year now. Over the weekend a loud buzzing warning alarm came on that will not turn off. I had it checked out and was quoted around 3500 to repair.

   NHTSA complaint #11745016 · source

Compare the 2011 Toyota Prius with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology