2015 Toyota RAV4 problems, complaints & recalls

2015 Toyota RAV4 recalls (4)

• Recall 23V734000Nov 1, 20231,853,568 vehicles
  ELECTRICAL SYSTEM:12V/24V/48V BATTERY

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.

  Risk: A battery short circuit increases the risk of a fire.

  Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.

• Recall 15V144000Mar 13, 2015110,085 vehicles
  STEERING:ELECTRIC POWER ASSIST SYSTEM

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.

  Risk: An unexpected loss of power steering increases the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.

• Recall 15V011000Jan 16, 20151,140 vehicles
  EXTERIOR LIGHTING · TRAILER HITCHES

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.

  Risk: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.

  Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.

• Recall 14V828000Dec 30, 20143,958 vehicles
  EQUIPMENT

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.

  Risk: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.

  Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.

NHTSA defect investigations

• PE21005Opened Feb 25, 2021Closed Aug 12, 2024led to recall 23V734

  Battery Hold Down Bracket Thermal Events

  The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to cont…

NHTSA 5-Star safety ratings

Recent 2015 Toyota RAV4 complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Oct 1, 2026TXSteering

   The steering "micro" sticking in steps for last 4 years. Talked to the Cedar Park Toyota dealership, they informed that there was no recall on the vehicle. But I found recall # 15V-144. I never received a recall notice. Always observes sticking a low speeds. Concerned about steering lock up. What should I do to fix it?

   NHTSA complaint #11768390 · source
2. Filed Sep 19, 2026TXElectrical SystemSteering

   While driving my 2015 Toyota RAV4 XLE 2WD (2.5L, about 207,000 miles), the electric power steering assist failed instantly with no warning, making the steering wheel feel locked. At the same moment, the infotainment screen went black and rebooted. It has happened at freeway speeds and at low neighborhood speeds, including on 9/14 and 9/15/2026, and also more than once last year (2025). No warning light or messages appeared beforehand. An OBD2 scan at AutoZone on 9/15/2026…

   NHTSA complaint #11765496 · source
3. Filed Aug 19, 2026FLBody & Structure

   In July 2026, the rear power liftgate on my Toyota RAV4 suddenly stopped operating properly and would not close. I was unable to push the hatch down normally and then noticed that one of the hinges appeared bent and the liftgate was misaligned. Because I needed to close the vehicle, I tried to lower the hatch very slowly, moving it down only a small amount at a time so I would not put additional pressure on the damaged hinge. While I was doing this, the hatch suddenly sprang…

   NHTSA complaint #11758067 · source
4. Filed Jun 25, 2026189,000 miAZDriver Assistance & Safety TechElectrical SystemSteering

   The contact owns a 2015 Toyota Rav4. The contact stated that the radio was inoperable. The contact stated that the gauges failed to properly operate. While driving 65 MPH, the vehicle lost power steering functionality. Additionally, the rearview camera image was reversed before becoming inoperable. The ABS, AWD, and engine warning lights were illuminated. The vehicle was taken to an independent mechanic, and an undisclosed fuse was replaced. The mechanic made the contact…

   NHTSA complaint #11746428 · source
5. Filed May 26, 2026MDOther / Unknown

   Car’s sunroof exploded while driving, was going about 55 on the highway and I heard a loud pop followed by the sound of breaking glass which I found to be my whole sunroof exploding from the inside out. This is dangerous because of the possibility of glass landing on people or in the car leading to potential injury. This issue is apparently one that happens fairly commonly. The component has not been checked yet. There were no warning signs, just a swift explosion and damage.

   NHTSA complaint #11740146 · source
6. Filed May 19, 2026FLBody & Structure

   Purchased less than 2 months ago from Performance Mitsubishi in Delray Beach FL. Lift gate was not opening and closing properly. Yesterday the hinges broke and lift gate won't shut. It appears there is a class action lawsuit for this issue. I am now responsible for fixing this because the dealership won't.

   NHTSA complaint #11738886 · source
7. Filed Mar 2, 2026TXFireBrakesElectrical SystemEngine

   On Friday February 27, 2026 as the vehicle was being driven it caught fire. Fire department and sheriffs office was called to the scene. Vehicle fire was put out but the whole front end burned.

   NHTSA complaint #11721498 · source
8. Filed Jan 12, 2026VAOther / Unknown

   There were two recalls on paint chipping off the body of the car. The last one ended in Nov 2025 I think. BUT...there are many of us who had no idea there was a paint recall, me included. I brought my Rav (great car btw, no issues with how it runs at all) thru a car wash over Thanksgiving, and two softball size paint chips came off, probably due to high pressure water. I then researched the paint and found out that there WAS a recall but I just missed it. This recall needs…

   NHTSA complaint #11710487 · source

Compare the 2015 Toyota RAV4 with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology