2009 Toyota RAV4 problems, complaints & recalls

2009 Toyota RAV4 recalls (14)

• Recall 16V596000Aug 12, 2016337,449 vehicles
  SUSPENSION:REAR

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.

  Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

  Remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.

• Recall 16V396000Jun 2, 20167,749 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

  Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

  Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

• Recall 16V096000Feb 19, 20161,123,752 vehicles
  SEAT BELTS:REAR/OTHER

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.

  Risk: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.

  Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.

• Recall 15V689000Oct 22, 20151,814,284 vehicles
  VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

  Risk: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

  Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

• Recall 15V577000Sep 18, 2015423,456 vehicles
  VISIBILITY/WIPER

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.

  Risk: Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.

• Recall 14V743000Nov 19, 20143,233 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

  Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

  Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

• Recall 13V383000Aug 28, 2013780,584 vehicles
  SUSPENSION:REAR

  Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.

  Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.

• Recall 13V014000Jan 16, 20133,235 vehicles
  AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE · SEATS

  Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

  Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

  Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

• Recall 12V491000Oct 10, 20122,519,424 vehicles
  VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

  Risk: If the switch overheats, it may melt, possibly resulting in a fire.

  Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

• Recall 12V373000Aug 2, 2012780,584 vehicles
  SUSPENSION:REAR

  Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.

  Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.

• Recall 11V113000Feb 24, 20111,363,244 vehicles
  VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

  Toyota is recalling certain model year 2008 through 2011 lexus lx570, 2003 through 2009 toyota 4runner, and 2006 through 2010 rav4 vehicles. The accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.

  Risk: A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.

  Remedy: The remedy is now available. The safety recall began early april 2011. The remedy will involve modification or replacement of the accelerator pedal and replacement of any toyota all-weather floor mat. Owners may contact toyota at 1-800-331-4331 or lexus at 1-800-255-3987.

• Recall 10V035000Feb 3, 2010271,417 vehicles
  EQUIPMENT:OTHER:LABELS

  Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.

  Risk: This does not meet the standard requirements.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on may 27, 2010. Owners may contact gulf states toyota at 713-580-3300.

• Recall 10V036000Feb 3, 2010153,418 vehicles
  EQUIPMENT:OTHER:LABELS

  Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.

  Risk: A driver may overload a vehicle which may increase the risk of a crash.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast toyota at 1-800-301-6859.

• Recall 10V017000Jan 21, 20102,230,661 vehicles
  VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

  Toyota is recalling certain model year 2005-2010 avalon, model year 2007-2010 camry, model year 2009-2010 corolla, corolla matrix, rav4, model year 2010 highlander, model year 2008-2010 sequoia, and model year 2007-2010 tundra vehicles. Due to the manner in which the friction lever interacts with the sliding surface of the accelerator pedal inside the pedal sensor assembly, the sliding surface of the lever may become smooth during vehicle operation. In this condition, if condensation occurs on the surface, as may occur from heater operation (without a/c) when the pedal assembly is cold, the friction when the accelerator pedal is operated may increase, which may result in the accelerator pedal becoming harder to depress, slower to return, or, in the worst case, mechanically stuck in a partially depressed position.

  Risk: The accelerator pedal may become hard to depress, slow to return to idle, or, in the worst case, mechanically stuck in a partially depressed position, increasing the risk of a crash.

  Remedy: Dealers will install a reinforcement bar in the accelerator pedal which will allow the pedal to operate smoothly. Gm will notify owners for the pontiac vibe please see 10v-018. This service will be performed free of charge. The safety recall is expected to begin on february 5, 2010 and will be completed on march 15, 2010. Owners may contact toyota at 1-800-331-4331.

NHTSA defect investigations

• EA12006Opened Jun 14, 2012Closed Feb 12, 2013led to recall 12V491000

  Power Window Master Switch Fire

  On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers wil…

• PE12002Opened Feb 6, 2012Closed Jun 14, 2012

  Power Window Master Switch Fire

  ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be …

• RQ10003Opened Feb 16, 2010Closed Mar 1, 2011led to recall 11V112000

  Unintended and Uncontrolled Acceleration

  On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additiona…

Recent 2009 Toyota RAV4 complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed May 22, 2026NJSteeringSuspensionWheels & Tires

   We were informed of safety recalls for our Toyota Rav 4 2009 . We called the local Toyaota dealership for the recalls and was told on the phone after we dropped it off that they did the inspection to make sure the recalls could be completed and informed us that they could ,but they needed to keep overnight because they had to order the parts. Prior to dropping the vehicle off the car was able to be driven and no known issues were visible. Received call following told to come…

   NHTSA complaint #11739536 · source
2. Filed May 11, 2026IDOther / Unknown

   I am writing to report a suspected case of odometer fraud involving a vehicle currently listed for sale at Stacey’s Auto Sales, located at [XXX] . Vehicle Details: 2009 Toyota RAV4 Sport VIN: [XXX] Asking Price: $8,995 Current Listed Mileage: 108,540 I obtained an NMVTIS vehicle history report which shows this vehicle was listed at a dealer (Revolutionary Auto) in December 2020 with 150,439 miles on the odometer. The vehicle is currently being sold with only 108,540 miles —…

   NHTSA complaint #11737014 · source
3. Filed May 4, 2026WISuspension

   Repairs of the control arms indicated on recall NHTSA 16V-596 were never done on my vehicle after the recall was issued in 2016. Smart motors Toyota in Madison confirmed that the replacement of the control arms was never done on my vehicle, but they are showing no open recalls on my vehicle in their system due to this being a re-recall. From what I've read many vehicles were incorrectly marked "complete" after the 2012 inspection, but the 2016 update (G0V) was issued…

   NHTSA complaint #11735702 · source
4. Filed Apr 20, 2026230,000 miTNEngine

   The contact owns a 2009 Toyota Rav4. The contact stated that there was an abnormal grinding sound coming from the engine at startup. There was no warning light illuminated. The vehicle was taken to an independent mechanic, and the contact was informed that the engine was consuming an excessive amount of engine oil caused by a gasket failure inside a piston in the engine. Due to the failure, the contact was frequently adding oil to the engine. The vehicle was taken to a…

   NHTSA complaint #11732512 · source
5. Filed Oct 24, 2025WAEngine

   Engine timeing system rattle on startup. Even basic web research shows this is a common problem for select model years and acorss mulitple models. This issue has a high probility of causing catastrophic engine damage, where the timeing chain & VVT system fails to keep timing causing the valves to colide with the pistons. There is a TOTAL ENGINE FAILURE risk with each and every engine start. The fix on the 3.5L requires the engine to be removed, VVT and timing chain tensioner…

   NHTSA complaint #11695436 · source
6. Filed Aug 17, 2025OROther / Unknown

   I was hit with a rock right between my eyes while driving, took Toyota into shop they were surprised it had not fell in on my lap. Window frame has corroded, glass shop said the manufacturer did not paint were the seals meet around the window and has allowed moisture in and corroded the frame. I have 160,000 miles on a Toyota that the window could fail anytime.

   NHTSA complaint #11681160 · source
7. Filed Mar 25, 2024NCBody & Structure

   We have a 09 Toyota Rav4 with a Blizzard Pearl paint that continues to fail. Apparently there were notices sent out in 2022 indicating a recall that would cover these repairs. We were unaware of these notices and continue to experience paint degradation on multiple areas of the car. I have contacted Toyota and they claim no responsibility past the 2022 expiration date. I am hoping that NTSB will reopen the recall regarding this issue. Sincerely, [XXX] INFORMATION REDACTED…

   NHTSA complaint #11579300 · source
8. Filed Jan 16, 2024MASuspension

   My son was looking to get his new tires aligned, and was informed by the mechanic that he would need to replace both side rear lower control arms, as Toyota had performed a safety recall GOV, resulting in the arms being epoxied, and therefore cannot be adjusted/ aligned. I contacted Toyota customer experience center [phone removed] - 1/16/2024) and she could not even call up the original recall. My question is: How can Toyota permanently remove a vehicle feature…

   NHTSA complaint #11565720 · source

Compare the 2009 Toyota RAV4 with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology