2007 Toyota RAV4 problems, complaints & recalls

2007 Toyota RAV4 recalls (13)

• Recall 16V596000Aug 12, 2016337,449 vehicles
  SUSPENSION:REAR

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.

  Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

  Remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.

• Recall 16V396000Jun 2, 20167,749 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

  Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

  Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

• Recall 16V096000Feb 19, 20161,123,752 vehicles
  SEAT BELTS:REAR/OTHER

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.

  Risk: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.

  Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.

• Recall 15V689000Oct 22, 20151,814,284 vehicles
  VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

  Risk: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

  Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

• Recall 14V743000Nov 19, 20143,233 vehicles
  SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

  Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

  Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

• Recall 14V168000Apr 9, 20141,486,413 vehicles
  AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

  Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.

  Risk: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.

  Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.

• Recall 13V383000Aug 28, 2013780,584 vehicles
  SUSPENSION:REAR

  Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.

  Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.

• Recall 12V491000Oct 10, 20122,519,424 vehicles
  VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

  Risk: If the switch overheats, it may melt, possibly resulting in a fire.

  Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

• Recall 12V373000Aug 2, 2012780,584 vehicles
  SUSPENSION:REAR

  Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.

  Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.

• Recall 11V245000Apr 21, 2011307,848 vehicles
  AIR BAGS · AIR BAGS:SIDE/WINDOW

  Toyota is recalling certain model year 2008 highlander, highlander hybrid, and model year 2007-2008 rav4 vehicles. In the curtain shield airbag (csa) system, there are two sensors in the airbag sensor assembly which are designed to detect vehicle roll angle. If one of these sensors malfunctions, the airbag warning light (malfunction indicator light: mil) will illuminate and the roll detection system will be suspended; however, the airbag csa remains available in the event of a side crash. If both sensors fail nearly simultaneously after initial airbag system check, the csa and the seat belt pretensioner could be inadvertently activated.

  Risk: Inadvertent activation of the csa and/or the seat belt pretensioner can cause injury to a vehicle occupant.

  Remedy: Toyota will replace the airbag sensor assembly with a new one containing improved roll rate sensors, free of charge. Toyota intends to send an interim owner notification to owners early to mid-may, 2011 when sufficient parts and remedy becomes available. Owners may contact toyota at 1-800-331-4331.

• Recall 11V113000Feb 24, 20111,363,244 vehicles
  VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

  Toyota is recalling certain model year 2008 through 2011 lexus lx570, 2003 through 2009 toyota 4runner, and 2006 through 2010 rav4 vehicles. The accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.

  Risk: A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.

  Remedy: The remedy is now available. The safety recall began early april 2011. The remedy will involve modification or replacement of the accelerator pedal and replacement of any toyota all-weather floor mat. Owners may contact toyota at 1-800-331-4331 or lexus at 1-800-255-3987.

• Recall 10V036000Feb 3, 2010153,418 vehicles
  EQUIPMENT:OTHER:LABELS

  Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.

  Risk: A driver may overload a vehicle which may increase the risk of a crash.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast toyota at 1-800-301-6859.

• Recall 10V035000Feb 3, 2010271,417 vehicles
  EQUIPMENT:OTHER:LABELS

  Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.

  Risk: This does not meet the standard requirements.

  Remedy: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on may 27, 2010. Owners may contact gulf states toyota at 713-580-3300.

NHTSA defect investigations

• EA12006Opened Jun 14, 2012Closed Feb 12, 2013led to recall 12V491000

  Power Window Master Switch Fire

  On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers wil…

• PE12013Opened Jun 4, 2012Closed Sep 13, 2012led to recall 12V373000

  Rear Suspension Arm Assembly Failure

  In a letter dated August 1, 2012 Toyota Motor Engineering & Manufacturing North America, Inc. (Toyota) submitted a Defect Information Report (NHTSA Recall No. 12V-373) to the NHTSA identifying a safety defect regarding possible separation of the Rear Suspension Arm No. 1 Assembly (arm) at the threaded portion (shaft and turn buckle) of the component in MY 2006 through MY 2011 Toyota RAV4 vehicles built from October 2005 through September 2010 and in MY 2010 Lexus HS250h vehicles manufactured from July 2009 through August 2010.According to Toyota, if the adjustment nuts for the rear wheel align…

• PE12002Opened Feb 6, 2012Closed Jun 14, 2012

  Power Window Master Switch Fire

  ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be …

• RQ10003Opened Feb 16, 2010Closed Mar 1, 2011led to recall 11V112000

  Unintended and Uncontrolled Acceleration

  On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additiona…

Recent 2007 Toyota RAV4 complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Oct 28, 2025NYFireElectrical System

   My driver side door caught on fire and was completely destroyed to include all associated wiring. Toyota had my contact information but never contacted me about any of the recalls.

   NHTSA complaint #11696168 · source
2. Filed Sep 15, 2025182,342 miFLSuspension

   The contact owns a 2007 Toyota Rav4. The contact stated that the vehicle could not be aligned. There were no warning lights illuminated. The vehicle was previously taken to the local dealer to be repaired under NHTSA Campaign Number: 16V596000 (Suspension). The vehicle was taken to a tire shop, and the contact was informed that the rear tie rods were welded, and an alignment was impossible. The manufacturer was contacted, but no additional assistance was provided. The…

   NHTSA complaint #11687356 · source
3. Filed Sep 8, 2025AZAirbagsOther / Unknown

   Other people keep using my Bluetooth from my Toyota RAV4 2007. I don't even use it anymore. I found out because my android vehicle app keeps activating. Also, I live in a apartment complex, and notice when I look out my window, people walk by and slow down and stop right in front of my car and start messing with their phone. It appears they are hacking into the Bluetooth. I've also had much financial theft from my bank account.. including I paid for my auto insurance months…

   NHTSA complaint #11685604 · source
4. Filed May 24, 2025AZAirbagsOther / Unknown

   Unknown I just strongly feel like I'm not getting the information on purpose..it has caused me much stress. I'm really upset. I've not once received any communication from you since I bought this vehicle 2nd hand. In 2018.. And to make matters worse, I've had my vehicle plates stolen 3 separate times including my cell phone number ( had to change it) and my driver license number was changed. I'm not having any help from my state DMV. Please help me.

   NHTSA complaint #11662984 · source
5. Filed May 15, 2025222,822 miGASteering

   The contact owns a 2007 Toyota Rav4. The contact stated while driving 40 MPH, the steering wheel seized. The contact was able to regain control of the vehicle. There were no warning lights illuminated. The vehicle was taken to an independent mechanic. The local dealer was not contacted. The vehicle was not yet diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 222,822.

   NHTSA complaint #11661161 · source
6. Filed Apr 2, 2025NJElectrical System

   The contact owns a 2007 Toyota Rav4. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to an independent mechanic where it was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The vehicle was repaired; however, the failure recurred. The dealer was not contacted. The vehicle was not diagnosed…

   NHTSA complaint #11652383 · source
7. Filed Mar 5, 202593,000 miNHBrakes

   The contact owns a 2007 Toyota Rav4. The contact stated that after shifting into reverse, the brake pedal was fully depressed; however, the vehicle failed to stop as needed and remained reversing slowly. The contact frantically turned off the vehicle to avoid crashing into the vehicle behind. There were no warning lights illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The…

   NHTSA complaint #11646524 · source
8. Filed Dec 9, 2024GADriver Assistance & Safety TechEngineSuspension

   The contact owns a 2007 Toyota Rav4. The contact stated while driving at various speeds, there was an abnormally loud sound coming from underneath the vehicle. The vehicle was taken to an independent mechanic, where the contact was informed that the sound was coming from the tires. The contact was informed that no issues were found. Additionally, the contact stated that the check engine warning light, the traction control warning light, and an unknown warning light were…

   NHTSA complaint #11629684 · source

Compare the 2007 Toyota RAV4 with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology