2013 Chevrolet Volt electrical system problems

Related recalls

• Recall 15V145000Mar 13, 201550,236 vehicles
  ELECTRICAL SYSTEM:IGNITION · ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

  General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.

  Risk: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.

  Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.

What owners say

1. Filed Feb 26, 2026LAAirbagsElectrical SystemSeats & Seat Belts

   The passenger presence sensor is failing or failed because every time someone sit in there the airbag turns on and off repeatedly every 2-3 mins and gives a service airbag warning and if no one is sitting in the passenger seat then it just stays on. Could be really dangerous if a wreck happens while it’s glitching in the off mode and could cause death. Multiple people have had this problem with the volts and there is even a thing you can by to completely bypass the airbag…

   NHTSA complaint #11720796 · source
2. Filed Feb 4, 2026GAElectrical SystemEngineFuel, Hybrid & EV Propulsion

   I received the "Propulsion Power is Reduced" Alert engine light while driving in "Normal" mode on the freeway at around 60mph with 8-9 miles of Battery capacity, it showed 0 miles of Battery forcing the Gas Engine on and the vehicle hesitated upon applying the accelerator for the remainder of the drive. My safety and that was others was at risk because the acceleration dropped quickly and I was on a busy freeway at the time when the Alert happened causing further hesitation.…

   NHTSA complaint #11715715 · source
3. Filed Dec 16, 2025141,323 miNETowedElectrical SystemEngine

   The contact owns a 2013 Chevrolet Volt. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The Check Engine warning light was flashing, and the messages "No Propulsion Power" and "No Power To Engine" were displayed. The contact stated that two individuals pulled over and assisted the contact in pushing the vehicle to the side of the road to prevent a crash. The vehicle was towed to an independent mechanic, who made the contact aware of an…

   NHTSA complaint #11705337 · source
4. Filed Mar 31, 202561,000 miKYElectrical SystemFuel, Hybrid & EV Propulsion

   The contact owns a 2013 Chevrolet Volt. The contact stated while driving approximately 76-77 MPH, the vehicle experienced reduced power. The message "Low Propulsion" was displayed, and the engine revved significantly. The contact moved over to the far-right lane to pull over to the side of the road as needed. The contact stated that the failure had been recurring temporarily. The contact had researched the failure online and became aware that the release of the accelerator…

   NHTSA complaint #11651727 · source
5. Filed Apr 26, 2024186,000 miGAElectrical System

   The contact owns a 2013 Chevrolet Volt. The contact stated that while driving at approximately 45 MPH, the vehicle stalled. The vehicle was able to be restarted. There were no warning lights illuminated. The contact stated that the failure persisted, and the propulsion system warning light was illuminated. The vehicle was taken to the dealer who diagnosed and determined that the battery needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of…

   NHTSA complaint #11585457 · source
6. Filed Apr 24, 2024CAElectrical SystemFuel, Hybrid & EV Propulsion

   When starting the vehicle, which had some charge on the batteries, the engine immediately started and a message appeared on the speedometer screen which stated, "Propulsion Power Reduced,” and another message said, “speed limited to 25mph.” I was in a very busy part of Hollywood running errands for my job when this happened. I felt very unsafe driving under these circumstances as I often need to drive above 25mph to keep up with traffic and cross busy streets to avoid other…

   NHTSA complaint #11585069 · source
7. Filed Dec 25, 2023ILElectrical SystemEngineFuel, Hybrid & EV Propulsion

   I was driving my plugin hybrid Volt on a highway when the engine stalled and the engine light turned on. I tap the throttle a few times to get it to stay on. It worked, but I had to continue to tap the throttle to keep it going. It also revved up sharply when it was in low gear. The vehicle was out of battery, so it was as running on engine.

   NHTSA complaint #11561788 · source
8. Filed Dec 5, 2023CAElectrical SystemFuel, Hybrid & EV Propulsion

   I received a notification on the dashboard that the engine is not in service and propulsion has been reduced. The car is available for inspection upon request. The safety and myself has been deeply compromised because the issues cause the car to suddenly not accelerate without warning. The issue happened to me on a freeway and could have caused an accident due to the engine and propulsion systems stop functioning without warning. The vehicle has been inspected. There were no…

   NHTSA complaint #11558652 · source
9. Filed Aug 18, 2023OHElectrical System

   High voltage charging system.. changed out the coolant sensor and the bypass coolant value and still getting high charging error.. machanics can’t figure out the issue and now we can use it as an electric car.. light returns after sitting for an hour and a half in the off position.. something is clearly wrong with the design of the electric side of the car

   NHTSA complaint #11539281 · source
10. Filed Jul 3, 2023CAFireElectrical System

    I arrived at the charging station and plugged the charging handle into the charge port. At this time an audible shorting sound was heard coming from inside the handle followed by a burst of flames and white smoke. This flame immediately went out and the smoke subsided slightly before building back up and darkening. By the time that the fire department arrived, the car's engine had caught fire resulting in a total loss. Additionally, the charging handle of the station had…

    NHTSA complaint #11530200 · source
11. Filed Nov 8, 2022FL1 injuredTowedElectrical System

    The contact owns a 2013 Chevrolet Volt. The contact stated that the electric battery would not charge and the vehicle was towed to the local dealer who diagnosed that the 12v battery was faulty and needed to be replaced. The 12v battery was replaced and the failure was remedied. The contact stated that later while driving the central battery pack located under the center console had overheated causing a loud noise within the cabin of the vehicle. The contact had sustained a…

    NHTSA complaint #11492761 · source
12. Filed Oct 26, 2022CAElectrical System

    The High Voltage charging system error message has chronically been triggered despite numerous mechanic visits, sensor and coolant replacement. I am now told this is a software issue and hope to have it resolved. This issue has cost hundreds of dollars in inspection and troubleshooting and hundreds of gas miles that should have been EV driven. The error prevents EV charges and I must rely on the gas back up.

    NHTSA complaint #11491035 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology