2013 Ford Explorer engine problems

Related recalls

No recalls on file.

What owners say

1. Filed Sep 17, 2026OKEngine

   The water pump on these explorers are internal and if not caught by a professional in time, the water pump will fail and cause catastrophic engine failure

   NHTSA complaint #11764873 · source
2. Filed Feb 24, 2026CTEngineOther / UnknownSteering

   I am submitting a formal safety complaint regarding a severe design defect in the 3.5L V6 engine of my 2013 Ford Explorer. The vehicle is equipped with an internal, chain-driven water pump that is currently failing at 100000 miles, as evidenced by coolant actively draining from the factory weep hole. Because this pump is located inside the engine block and driven by the timing chain, a complete seal failure dumps engine coolant directly into the oil pan. This is a critical…

   NHTSA complaint #11720077 · source
3. Filed Dec 3, 2025MOEngineSteeringSuspension

   I was leaving the store pulled out on a main road in town about to head on the highway. My steering wheel locked and would hardly move with all my strength and the help of my significant other we pulled back into the store parking lot rarely missing hitting several vehicles in the process. I had my children with me at the time in this vehicle as well. The power steering assist fault message popped up. I had the vehicle towed to Ford Groves and after a diagnostic test was ran…

   NHTSA complaint #11702622 · source
4. Filed Jun 3, 2025250,000 miMNFireTowedEngine

   The contact owns a 2013 Ford Explorer. The contact stated that while the vehicle was parked unattended and turned off for a few hours, it caught fire. There were no warning lights illuminated prior to the failure. The fire department extinguished the fire. There were no reported injuries airbag deployment or crash. The vehicle was towed to a police tow lot. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The…

   NHTSA complaint #11664641 · source
5. Filed Jan 28, 2025NJEngine

   Recently, I experienced a catastrophic water pump failure that has resulted in extensive damage to my vehicle’s, a 2013 Ford Explorer equipped with a cyclone engine, engine and turbocharger Details of the Incident According to Ford of Englewood, NJ, the water pump failure in my Explorer caused coolant to seep into the oil pan, mixing with other fluids. This has resulted in the need for a complete replacement of both the engine and turbocharger, at an estimated cost of…

   NHTSA complaint #11639231 · source
6. Filed Dec 30, 2024NYBody & StructureEngine

   The contact owns a 2013 Ford Explorer. The contact stated that the driver’s and passenger’s side exterior A-pillar around the front windshield was detaching. The contact placed the A-pillars back in position. The contact stated that water was leaking into the vehicle. The contact stated that the check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet…

   NHTSA complaint #11633054 · source
7. Filed Nov 4, 202414,000 miNVEngine

   The contact owns a 2013 Ford Explorer. The contact stated that after starting the vehicle, the check engine warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed but the cause of the failure was not yet determined. The check engine warning light was reset, and the contact was informed that the check engine warning light was due to the air filter that needed to be replaced. The vehicle was repaired; however, the failure recurred. The…

   NHTSA complaint #11623533 · source
8. Filed Oct 26, 2024NDElectrical SystemEngineSeats & Seat Belts

   The heat in my 2013 Ford Explorer won't work. The Rad fan isn't working so any antifreeze I put in is gone after 1 trip to the store. It's burning it. The sunroof has never opened fully, it wobbles. The electrical is shot on it. There are so many safety issues with this vehicle and I see I'm not the only one but yet I search my Vin and there are no recalls that's not right

   NHTSA complaint #11622082 · source
9. Filed Sep 16, 2024NCEngine

   The engine water pump started leaking heavily (as discovered later) and the engine overheated in traffic. Since the water pump is located inside the engine, i have bee quoted an astronomical repair estimate of at lease $2,500 (including the parts) just to fix the water pump!! That is completely insane and apparently a design flaw, in my opinion, that I think the manufacturer should be responsible for.

   NHTSA complaint #11614802 · source
10. Filed Sep 4, 2024157,625 miFL2 injuredEngine

    The contact owns a 2013 Ford Explorer. The contact stated while driving, the contact noticed a strong unusual odor in the interior of the vehicle. The contact stated that the air conditioner was on, and the odor came through the vents. In addition, the contact stated that he and his minor child developed a headache and became nauseous. Medical attention was not sought as of yet. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The…

    NHTSA complaint #11612672 · source
11. Filed Jul 31, 202480,000 miMAEngine

    The contact owns a 2013 Ford Explorer. The contact stated while driving at various speeds, the vehicle was leaking coolant. There were no warning lights illuminated. The contact added additional coolant as necessary. The vehicle was taken to an independent mechanic, who determined that the water pump was leaking and needed to be replaced. The contact called the local dealer, who stated there was no recall coverage for the failure. The vehicle was not diagnosed or repaired.…

    NHTSA complaint #11605685 · source
12. Filed Jul 30, 2024144,300 miMIEngine

    The contact owns a 2013 Ford Explorer. The contact stated while the vehicle was parked, the coolant temperature warning light was illuminated. The contact stated that while driving to the nearest independent mechanic to add coolant to the vehicle, the engine was running rough as if the vehicle would stall. The contact pulled over and parked the vehicle. The contact walked to the independent mechanic and purchased coolant to add to the coolant reservoir. The vehicle operated…

    NHTSA complaint #11605335 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology