2017 Ford F-250 SD body & structure problems

Related recalls

• Recall 22V087000Feb 16, 2022247,445 vehicles
  POWER TRAIN:DRIVELINE:DRIVESHAFT · STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

  Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.

  Risk: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.

  Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.

• Recall 19V880000Dec 11, 2019490,574 vehicles
  SEAT BELTS:PRETENSIONER · STRUCTURE:BODY:ROOF AND PILLARS

  Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

  Risk: A vehicle fire could result if materials ignite inside the vehicle.

  Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.

• Recall 19V864000Dec 4, 2019231,664 vehicles
  LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

  Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.

  Risk: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.

  Remedy: Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.

• Recall 17V652000Oct 16, 20171,101,107 vehicles
  LATCHES/LOCKS/LINKAGES:DOORS:LATCH

  Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.

  Risk: A door that opens while driving can increase the risk of injury.

  Remedy: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.

What owners say

1. Filed Oct 25, 2024123,236 miPABody & StructureElectrical SystemFuel, Hybrid & EV Propulsion

   1 .Driver's side door will not close in cold weather due to frozen actuator. TSB has been issued on this problem; Ford will not repair due to vehicle being out of warranty. 2. Backup/vehicle camera's do not always work when truck is in reverse. TSB has been issued on this problem; Ford will not repair due to vehicle being out of warranty. 3. Ford inadvertently installed a substantially smaller fuel tank on my specific vehicle. TSB has been issued on this problem; Ford will…

   NHTSA complaint #11621975 · source
2. Filed Oct 17, 202490,000 miMOBody & Structure

   The contact owns a 2017 Ford F-250. The contact stated that while driving at various speeds, the tailgate would unexpectedly open without warning, causing material to fall out of the vehicle. Additionally, the contact stated that the tailgate would fail to open when pressing the button on the key fob or when attempting to manually open the tailgate. Upon investigation, the contact discovered NHTSA Campaign Number: 19V864000 (LATCHES/LOCKS/LINKAGES) which was linked to the…

   NHTSA complaint #11620361 · source
3. Filed Oct 8, 202496,000 miMDBody & StructureElectrical System

   The contact owns a 2017 Ford F-250. The contact stated that while driving at unknown speeds, the alarm system warning light was illuminated. The hood ajar message was displayed. The vehicle was taken to the local dealer, where it was diagnosed that the knock sensor and wiring harness needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 96,000.

   NHTSA complaint #11618761 · source
4. Filed Mar 18, 2024WIBody & StructureLighting

   The cab roof clearance lights leak water when it rains. The water leaks into the electronics in the overhead console and down the A-pillar. Dealer advises it is a nonwarranty issue under extended warranty and a commonly known issue on these. trucks.

   NHTSA complaint #11578000 · source
5. Filed Mar 6, 2024GABody & StructureOther / Unknown

   When temperature drops below freezing moisture get in door panels and freezes the locking system so that the does will not stay closed, making my truck unsafe to drive. This has happened multiple time when on the road was afraid for passenger and animals in the truck.

   NHTSA complaint #11575877 · source
6. Filed Jan 16, 202440,000 miOHBody & Structure

   The contact owns a 2017 Ford F-250. The contact stated that during cold weather conditions, the locking mechanisms on all four doors malfunctioned and the doors would not latch and remain securely closed. The vehicle was taken to the local dealer who diagnosed that the locking mechanisms were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact stated that the vehicle was…

   NHTSA complaint #11565726 · source
7. Filed Dec 29, 2023NMBody & Structure

   My vista sunroof on my 2017 F250 Super Duty Platinum made a popping noise and failed to open when I attempted to open it. It became bound to the rear glass which in turn commenced to fracture across the entire piece. Fortunately no one was injured as this glass could have dropped large shards into the cab. I an concerned that this could still present a problem when driving and is an imminent safety hazard. I found out that this is a common issue that Ford is aware of on the…

   NHTSA complaint #11562498 · source
8. Filed Sep 7, 202330,000 miFLBody & Structure

   The contact owns a 2017 Ford F-250. The contact stated that water had entered the vehicle through the dome light and leak from the door handles and instrument panel. The contact stated that the vehicle was taken to the dealer where the front windshield was initially replaced; however, upon investigation, it was later discovered that the dome light was the source of the leak, and the dome light was replaced. The contact then stated that while driving at an undisclosed speed,…

   NHTSA complaint #11543244 · source
9. Filed Jul 11, 2023150,000 miTXBody & Structure

   The contact owns a 2017 Ford F-250. The contact stated the front driver's side door lock was inoperable, causing him to be locked inside the vehicle on several occasions. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

   NHTSA complaint #11531667 · source
10. Filed Feb 15, 2023SCBody & StructureElectrical System

    Noticed that my floor is getting soaked for no reason. After looking online and reading about others that are experiencing the same issues I found out that is was the cabin pressure vent that was leaking. The cabin pressure vent is found between the truck bed and cab. They are plastic and since the plastic clips lose tightness over the years I did not notice a slow leak in the back. Now when pulling up all of the carpet I notice I have black mold all under the carpet where…

    NHTSA complaint #11507476 · source
11. Filed Dec 27, 202280,000 miPABody & Structure

    The contact owns a 2017 Ford F-250. The contact stated that the door actuators and locks froze, causing the doors to open. Additionally, the contact stated that in a -25 Fahrenheit wind chill, the door failed to unlock, and he was left outside of the vehicle. The contact broke into the vehicle. The contact stated he had used the seat belt to secure the door but was unable to open the door. There were no warning lights illuminated. The vehicle was taken to the dealer but was…

    NHTSA complaint #11498986 · source
12. Filed Dec 19, 202250,000 miPABody & Structure

    The contact owns a 2017 Ford F-250. The contact stated that after opening the front driver’s door, the locking mechanism malfunctioned, and the door would not remain closed. The contact indicated that the failure had occurred on multiple occasions and on both the front driver’s and front passenger’s side doors. The failure would occur when the weather temperature was below 20 degrees and raining, causing ice to form inside the locking mechanism. After the vehicle warmed up,…

    NHTSA complaint #11498110 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology