2019 Tesla Model 3 brakes problems

Related recalls

• Recall 21V387000May 25, 20215,974 vehicles
  SERVICE BRAKES, HYDRAULIC:CRITICAL FASTENERS · SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

  Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.

  Risk: Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.

  Remedy: Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.

What owners say

1. Filed Jul 30, 2026ALBrakes

   My brake lines have corroded to the point where half a liter of brake fluid has leaked out rendering the vehicle unsafe. Tesla admits that this is a design flaw but says that it does not affect this particular VIN number but the damage is exactly as described: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint #11753838 · source
2. Filed Apr 27, 2026AZCrash3 injuredTowedBrakes

   The Tesla was hit on the passenger side by a Honda civic that ran a red light traveling more than 25 mph The Tesla spun 180 degrees after impact. No airbags deployed. Immediately after impact the Tesla turned on hazard lights. However the vehicle would not come to a stop after pressing on the brakes. After impact the vehicle was coasting backwards at probably less than 5-6 mph. It would not respond to brake presses. Oddly the vehicle had regen braking enabled which should…

   NHTSA complaint #11734115 · source
3. Filed Dec 22, 2025GACrashTowedBrakes

   Brakes failed to stop the car. The car sat at Tesla service center for one month with no action from Tesla.My wife rear ended another car. The air bags deployed. No one was injuryed and the other was not damaged. Both people could have been seriously hurt or killed. Car was finally towed to Classic Collision November 24 by State Farm Insurance for repair. Estimate to be repaired January 8, 2026.

   NHTSA complaint #11706446 · source
4. Filed Jul 30, 2025CABrakesSteeringSuspension

   The vehicle’s front suspension began making loud squeaking noises and felt unstable while driving, especially when turning or going over uneven surfaces. At times, the vehicle does not make a proper turn and almost feels like it loses grip, which is extremely unsafe. I brought the vehicle to a Tesla service center. After inspection, Tesla provided a service estimate and documentation confirming the failure of the front lower lateral links — the exact part and condition…

   NHTSA complaint #11677252 · source
5. Filed Jul 7, 2025PABrakesDriver Assistance & Safety Tech

   [XXX]- [XXX]am. Trying to park in YMCA located in camp hill PA. Took soft right turn to park. Car accelerated instead of recognizing break, which I applied when I see it accelerating. Then I left break so it can take emergency break that didn’t happened it keep going and cross over the parking curb about six Torah inch high and went in a ditch. I did not hurt but car front damaged. Tesla was informed and they have the log of the time but told they don’t see any issue. My…

   NHTSA complaint #11671507 · source
6. Filed May 5, 2025OHBrakesDriver Assistance & Safety TechAcceleration & Cruise Control

   Phantom braking (as it's referred to by experts) happened to me twice on the highway using Traffic-Aware-Cruise-Control. Very scary. I was on cruise control going 60 mph when suddenly my car braked suddenly and inappropriately, losing at least 20 mph in a split second before I was able to slam on the accelerator and prevent an accident (rear-end collision). This happened TWICE in the course of 5 minutes on the same highway! There was no obstruction in the road, no cars…

   NHTSA complaint #11658874 · source
7. Filed May 4, 2025VABrakes

   The brake lines have completely failed on my 2019 Tesla Model 3 due to rust / corrosion in the drivers side front wheel well. Fortunately failure was caught before an accident occurred. Had I not caught this failure, at highway speed this could have resulted in a very bad accident putting me and my family in danger. After the failure occurred the vehicle indicated it had low brake fluid and that it should be taken to a Tesla service center. I had two different Tesla service…

   NHTSA complaint #11658771 · source
8. Filed Feb 18, 2025MIBrakesDriver Assistance & Safety TechAcceleration & Cruise Control

   When cruise control or self-driving systems are engaged, there have been numerous times when the automatic emergency braking system mistakenly slowed the car suddenly. At 70+ mph, this is incredibly dangerous. The AEBS apparently sees shadows as dangers. Fortunately, there has never been an instance when another vehicle has been close behind.

   NHTSA complaint #11643341 · source
9. Filed Nov 13, 2024CABrakesDriver Assistance & Safety Tech

   It brakes at highway speeds of 70 without reasons on cruise control and FSD. Happened three times on highway 46. It can be very bad if there was a car behind me. This happened to me through all these years since 2019.

   NHTSA complaint #11624913 · source
10. Filed Jul 13, 2024CABrakesDriver Assistance & Safety Tech

    The brakes of my car did not work on July 2023. I stepped on the brakes and the car did not stop. It accelerated. I almost crashed into another car as the car kept on going. The car beeped when getting close to another car & slowed. I had to maneuver the car to the side of the road to avoid a collision. It did not stop until the length of 2 cars. My husband checked my tesla car and saw there was an alert that the brakes did not work, however, he was unable to take a picture…

    NHTSA complaint #11601644 · source
11. Filed Jun 10, 2024NJBrakesElectrical SystemSteering

    I was driving my Model 3 when this alert occurred: ALERTS DRIVABILITY - VEHICLE MAY NOT RESTART/SERVICE IS REQUIRED ADDITIONALLY THE SCREEN STATED PULL OVER THE VEHICLE IMMEDIATELY SAFELY. I was in the middle of the road driving so it became dangerous. I could not steer the vehicle and the brakes were barely working. I could not immediately stop because I was in the middle of traffic. I pulled right over as soon as I could and shut down the vehicle. I believe this is a…

    NHTSA complaint #11593448 · source
12. Filed Apr 22, 2024MDBrakesDriver Assistance & Safety TechSteering

    The following recalls have been pending on my vehicle: 23V-838; TC2023-657, 24V-051 Tesla is unable to push over-the-air (OTA) updates to my vehicle to remedy these recalls due to an issue with the onboard computer being unable to receive updates. This issue arose when Tesla pushed a software/firmware update to my vehicle which effectively "bricked" the Advanced Drive System portion of the computer. In other words, I am unable to safely receive an update to resolve the…

    NHTSA complaint #11584617 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology