2019 Tesla Model 3 suspension problems

Related recalls

• Recall 23V235000Mar 31, 2023422 vehicles
  SUSPENSION:CRITICAL FASTENERS · SUSPENSION:FRONT

  Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.

  Risk: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.

  Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.

• Recall 21V835000Oct 25, 20212,791 vehicles
  SUSPENSION:CRITICAL FASTENERS · SUSPENSION:FRONT

  Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.

  Risk: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.

  Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.

What owners say

1. Filed Aug 3, 2026TXSuspension

   Noise came from front left wheel while driving around a turn. Later the same day another noise when turning the wheel when leaving a parking spot. Steering felt strange. It was late at night, so left the vehicle until the morning. In the morning, discovered a large bolt in front of the vehicle. The front left wheel was turned differently than the right front wheel. Had to spend almost $400 to get the vehicle towed to a Tesla service center. They later confirmed, "The cause…

   NHTSA complaint #11754524 · source
2. Filed Aug 3, 2026DCSuspension

   Over a period of several weeks, the front suspension increasingly made noise (squeaking and groaning) and felt loose when turning and going over bumps. The front control arms were replaced 10/31/24. The problem has begun recurring over the last few months, with the same noise occurring and progressively worsening.

   NHTSA complaint #11754415 · source
3. Filed Jul 31, 2026WASuspension

   Between 2023 and 2026, I have had several clunking and creaking sounds from the suspension. These were then found isolated to "lateral and compliance link detachments" and Tesla noted these were "serious safety issues" and fixed them out of warranty at a cost of roughly $2500. When I pointed out that vehicles within this model range (manufactured April 2019 at the Fremont, CA plant) were flagged for a recall, they mentioned my vehicle was outside that range and insisted on…

   NHTSA complaint #11754101 · source
4. Filed Jul 31, 2026CASuspension

   Honestly since I took delivery the vehicle I did notice a clunking sound every time I would turn into a steep driveway. I reported the problem to Tesla on multiple occasions and they either could not replicate the sound or find the problem when they inspected the vehicle. So I lived with the on and off clunking sound. Years later while driving on the freeway I heard a really hard clunk and I began to lose control of the car luckily I was close to home and I was able to make…

   NHTSA complaint #11754053 · source
5. Filed Jul 31, 2026ALSuspension

   About one month ago, my 2019 Tesla Model 3 developed a suspension issue that caused a noticeable vibration in the rear of the vehicle whenever I drove above 40 mph. At first, we suspected the problem was related to a tire. However, after the technicians at the Tesla Service Center lifted the vehicle for inspection, they discovered a much more serious issue. They brought me into the service area to show me that the right rear suspension was being held together by only the…

   NHTSA complaint #11754048 · source
6. Filed Jul 5, 2026CABody & StructureSuspension

   Summary of the Problem Rear subframe assembly and multiple rear suspension links required full replacement due to failure/wear at approximately 51,890 miles, on a vehicle with no history of collision or accident damage. Tesla diagnosed the issue as an interior rattle/squeak reproducible over bumpy roads and speed bumps, which led to replacement of the rear subframe and nearly the entire rear suspension link set. Total repair cost was approximately $7,667.65, entirely out of…

   NHTSA complaint #11748392 · source
7. Filed May 19, 2026MISuspension

   these cars have a defective control arm system and they are prone to messing up over and over, they have replacement revisions but try to charge you for labor and parts if youre out of warranty even though they know the parts were a problem and revised them. Tesla does nothing to help you and will even try to charge you $200 just to diagnose the issue.

   NHTSA complaint #11738879 · source
8. Filed Mar 14, 2026CASuspension

   Suspensions. I know there’s been known defects with the suspensions and they’ve only recall 422 vehicles so far (2018-2019 Tesla model 3, I feel more vehicles in those years are affected.

   NHTSA complaint #11724362 · source
9. Filed Feb 17, 2026TXSuspension

   While driving, the front driver-side suspension collapsed due to a complete detachment of the front lower lateral link. The fastener (bolt) backed out entirely and fell onto the road/under-shield. This matches the failure mode described in NHTSA Recall 21V-835, although Tesla has previously claimed my specific VIN was not included. The failure caused an immediate loss of steering control and structural instability. I am reporting this as a potential 'recall bypass' where the…

   NHTSA complaint #11718650 · source
10. Filed Feb 4, 2026CASuspension

    At approximately 30,000 miles, the front left suspension lateral link/control arm separated while driving due to a missing mounting fastener (bolt), resulting in sudden steering instability and abnormal front wheel movement. Vehicle handling became unpredictable and felt unsafe to control, creating risk of loss of steering control. I stopped driving immediately. There was no collision, curb strike, pothole, or road hazard at the time of the incident. No warning lights or…

    NHTSA complaint #11715496 · source
11. Filed Jan 3, 2026CAOther / UnknownSuspension

    I am reporting a safety defect involving a welded rear subframe component. The welded section snapped under normal driving conditions, and this is a safety-critical structural suspension component. There was no collision, misuse, or accident prior to this failure. The vehicle is currently not safe to drive due to the compromised rear suspension structure. I have included photos showing the snapped weld and overall rear subframe area. This appears to be a premature structural…

    NHTSA complaint #11708550 · source
12. Filed Dec 28, 2025ILSteeringSuspension

    After 3 prior repairs 2 of which were recalls of the front suspension, control arms. I was driving when me and my 3 children’s life’s were almost taken. While driving on the expressway immediate loss of control of the car shaking while driving to work, I stopped immediately thank God no cars around next to me to crash into. We called for a ride and walked off the expressway. Immediately car was taken to Tesla where they told me they couldn’t help and come back in a few days.…

    NHTSA complaint #11707311 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology