2022 Tesla Model Y body & structure problems

Related recalls

• Recall 24V554000Jul 24, 20241,849,638 vehicles
  ELECTRICAL SYSTEM:SOFTWARE · LATCHES/LOCKS/LINKAGES:HOOD:LATCH

  Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.

  Risk: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.

  Remedy: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.

What owners say

1. Filed Aug 30, 2026WABody & Structure

   Child entered our vehicle and was UNABLE to exit/open his door (driver's side passenger door) from inside. The child locks were not enabled. The door would also NOT open from the outside. When entering service mode, a VCLEFT_a187latchReleaseFailedR error was present. I looked up on Tesla service how to manual release the door. It states to use a fingernail or flat tool to open the plastic flap in the pocket of the door handle. I was unable to open with a my fingernail and…

   NHTSA complaint #11760729 · source
2. Filed Aug 26, 2026WABody & Structure

   Tailgate doesn’t close. Electric hydraulic arm on driver side is too strong forcing misalignment of tailgate. Tesla will not repair under warranty.

   NHTSA complaint #11759724 · source
3. Filed Aug 26, 2026CACrash2 injuredTowedBody & StructureBrakesDriver Assistance & Safety Tech

   FSD (Supervised) was engaged while the vehicle was traveling toward a freeway entrance. The vehicle was expected to turn right, but instead began veering left. The driver applied the brake in an attempt to slow the vehicle and disengage FSD. According to the driver’s recollection, the vehicle did not respond as expected and continued accelerating until it left the roadway and crashed into a ditch. The incident created a serious safety risk to the driver and an infant…

   NHTSA complaint #11759612 · source
4. Filed Jun 28, 2026CABody & StructureElectrical SystemOther / Unknown

   On Saturday, [XXX] at around [XXX] going west on [XXX] toward [XXX] stopped at the intersection of [XXX]. While driving my 2022 Tesla Model Y, Performance, I was stopped at a red light. When the light turned green and I began accelerating normally through the intersection, both passenger-side doors unexpectedly unlatched at the same time. The windows on both passenger doors lowered slightly, and the vehicle displayed a warning indicating the doors were open and to drive…

   NHTSA complaint #11747051 · source
5. Filed Jun 10, 2026CA1 injuredBody & Structure

   When exiting the driver seat of the vehicle my left arm gets caught in the hinge of the back door. This has happen before. This time my arm was bruised bad and shoulder painfully wrenched. The pain was so bad I thought my arm was broken.

   NHTSA complaint #11743272 · source
6. Filed May 9, 2026NCBody & Structure

   2021built -2022 Model Y rear doors manual release door cable is really hard and impossible without tool to access. first removing the rubber pad is annoying because there is no lip sticking out to grab and remove easily, then it comes to the small plastic access to the manual door release cable, without tools it’s impossible to open, it would destroy finger nails and get cuts around fingers trying to open it. even after getting open the small access trim is still really hard…

   NHTSA complaint #11736737 · source
7. Filed Mar 24, 2026VABody & StructureOther / Unknown

   Tesla Model Y Performance with 47,000 miles. Driver's side, rear passanger door would not open. No accident or damage to the car or car door. Door could not be opened from the inside nor the outside with the handle. ISSUE: The Emergency Door release in the pocket of the door failed to release and open the door.

   NHTSA complaint #11726708 · source
8. Filed Mar 17, 2026FLBody & Structure

   While driving on Intestate I-95 in the Express Lane at high speed in my 2022 Tesla Model Y, the hood (frunk) suddenly flew open, smashed into the windshield and remained in the upright position. Luckily I was able to slow down and ease blindly into the emergency lane without causing further damage to myself or others. I lost entire visibility at high speed and my windshield was smashed on the highway. This was a traumatic experience that could have caused serious damage to…

   NHTSA complaint #11725019 · source
9. Filed Oct 17, 202542,678 miILBody & StructureElectrical System

   On July 22, 2025, at about 6:30 PM in a western suburb of Illinois, on a hot, humid, sunny evening after my car had sat in direct sun all day, my 2022 Tesla Model Y Long Range (Dual Motor AWD) suffered a total electrical failure. As I walked up, the car unlocked automatically with my phone key as usual. I placed my dog in the back seat, closed that door, and immediately tried to open the driver’s/front door—but it would not open. The phone key failed, and the backup key card…

   NHTSA complaint #11694211 · source
10. Filed Sep 16, 2025CABody & StructureElectrical System

    on July 19, 2025 my 10-year old daughter entered the back seat and shut the door. When I (her mother) went to get into the drivers door the electricity in the car completely shut down locking my daughter in the vehicle. There were no visible icons or labels showing where the emergency/manual latch was. She was hystercial and heating up quickly. We called Tesla roadside assistance and the agent spent 10-15 minutes explaining how to get out of a Model 3 (we had a model Y). He…

    NHTSA complaint #11687672 · source
11. Filed Sep 16, 2025SCBody & StructureElectrical System

    I saw that the US National Highway Traffic Safety Administration is investigating the Tesla Model Y (2021 and over) due to the electronic door handles becoming inoperative. I am happy and relieved to see this is being looked into since this recently happened to my vehicle a couple of months ago. The rear passenger side door unlocked initially for me to put by [XXX] old into the car seat but when I went to open the driver's side door, the handles would not open. I tried all…

    NHTSA complaint #11687532 · source
12. Filed Aug 25, 2025CABody & StructureSuspensionWheels & Tires

    I initially brought my car in for a weird clicking noise. This noise went away after the car was towed to the Service Center. During service at Tesla Service Center in LA on August 04, 2025, technicians identified structural deformation of the left-hand rear subframe toe link mounting side wall. This deformation prevents proper alignment of the suspension bolt and makes a 4-wheel alignment impossible. Tesla refused warranty coverage, claiming “impact damage,” citing only…

    NHTSA complaint #11683017 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology