2022 Tesla Model Y wheels & tires problems

Related recalls

• Recall 24V935000Dec 17, 2024696,281 vehicles
  TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

  Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

  Risk: Driving with improperly inflated tires increases the risk of a crash.

  Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.

What owners say

1. Filed Oct 8, 2026CAWheels & Tires

   I am reporting a potentially serious tire safety failure involving a Continental ProContact RX, size 255/45R19 104W XL, installed on a 2022 Tesla Model Y. The tire was purchased new and installed by Tesla on January 15, 2026. In September 2026, while driving, the tire experienced a sudden catastrophic failure. The sidewall was extensively torn and separated circumferentially around the wheel, while substantial portions of the tread remained intact. The tire carcass was left…

   NHTSA complaint #11769931 · source
2. Filed Aug 18, 202699,482 miCATowedWheels & Tires

   The contact owns a 2022 Tesla Model Y equipped with Michelin Tires, Tire Line: Michelin Pilot Sport, Tire Size: 255/35/ZR21, DOT Number: (N/A). The contact stated that while driving 65 MPH, the rear driver’s side tire experienced a blowout. The contact was able to safely pull off the roadway and wait for towing assistance. The local dealer was contacted. The vehicle was towed to American Depot Tires. The contact stated that all four tires were replaced, and the vehicle was…

   NHTSA complaint #11757662 · source
3. Filed Aug 17, 2026NYSuspensionWheels & Tires

   2022 Tesla Model Y - Premature inner rear tire wear due to excessive negative camber from factory. Both rear tires worn to cords on inside edge at 17k miles, outside tread 6/32 still. Alignment specs show rear camber out of spec caused by short factory rear camber arms. This is a known defect, creates blowout risk at highway speed. Vehicle never modified, never in accident. Mileage 113,136. I have photos. Bronx NY.

   NHTSA complaint #11757480 · source
4. Filed Jul 6, 2026CAOther / UnknownSteeringWheels & Tires

   "I have a Tesla Model Y that experienced what looks like a steering malfunction, with documented data and repair records already in hand. "While driving our 2024 Tesla Model Y when the steering wheel suddenly turned itself, hard left, and driver couldn't regain control. The car went up a hillside, between a utility/ electricity pole and an electrical box, coming to a stop just inches from the pole. No injury, but real vehicle damage." "I pulled Tesla's own vehicle data log…

   NHTSA complaint #11748516 · source
5. Filed Jun 10, 2026NYWheels & Tires

   Model Y (VIN: [XXX]). On XXX, I brought my vehicle to Tesla Service for replacement of the front wheel hub assembly and paid approximately $1,000 for the repair. Shortly after picking up the vehicle, I noticed abnormal knocking and clicking noises while turning the steering wheel. Because I was concerned about the safety of the vehicle, I sought a second opinion from an independent repair facility. On XXX, the independent shop inspected the vehicle and found that two wheel…

   NHTSA complaint #11743366 · source
6. Filed May 14, 2026WAElectrical SystemWheels & Tires

   While driving, the vehicle displays a critical “Air pressure in tires very low — pull over safely” alert. When I pull over and inspect, the tire pressure is normal and there is no flat. The alert clears on its own after driving a few more miles. The vehicle has been serviced four times for this issue between February and May 2026 at Tesla service centers in Austin TX, Flower Mound TX, San Diego CA, and Los Angeles CA. The tire pressure monitoring sensors have been replaced…

   NHTSA complaint #11737798 · source
7. Filed Feb 5, 2026CABrakesWheels & Tires

   While driving, the front left brake caliper detached, causing immediate damage to the wheel and a tire blowout. There was no recent brake, wheel, or suspension service (over two years). Tesla is repairing the vehicle for an estimated $2,336.41 but did not clearly identify root cause. This was a sudden brake system failure that could have resulted in loss of control. I am reporting this as a potential safety defect.

   NHTSA complaint #11716035 · source
8. Filed Feb 3, 2026TXWheels & Tires

   A tire experienced a sudden bead-area blowout while the vehicle was traveling at freeway speed. There was no pothole, curb, debris, or roadway impact. The failure occurred approximately ten days after installation. Inspection shows failure at the tire bead adjacent to a wheel defect. The wheel was represented as new at installation but shows evidence of prior material removal and cosmetic reconditioning, including rounded aluminum exposure and surface striations inconsistent…

   NHTSA complaint #11715375 · source
9. Filed Nov 19, 2025COCrashWheels & Tires

   Tesla Collison Center Denver - returned vehicle with bent wheel after an accident They refuse to repair despite safety risk They are now Blocking my access to service of fixing my car for unrelated issues as well. This bent wheel may result in an unsafe vehicle on the road

   NHTSA complaint #11700424 · source
10. Filed Oct 21, 2025VASuspensionTransmission & DrivetrainWheels & Tires

    The Tesla model Y Performance has a tire wear problem that causes uneven wear and creates cupping that occurs within 7500 miles of tire wear. There is also a weird sound even when you have new tires on the vehicle. The noise grows as your speed goes up it is almost painful at 70mph. It is a known issue and Tesla refuses to address the problem even though they are aware of it. This cupping issue creates a loud noise within the vehicle and reduces the tire mileage to under…

    NHTSA complaint #11694842 · source
11. Filed Aug 25, 2025CABody & StructureSuspensionWheels & Tires

    I initially brought my car in for a weird clicking noise. This noise went away after the car was towed to the Service Center. During service at Tesla Service Center in LA on August 04, 2025, technicians identified structural deformation of the left-hand rear subframe toe link mounting side wall. This deformation prevents proper alignment of the suspension bolt and makes a 4-wheel alignment impossible. Tesla refused warranty coverage, claiming “impact damage,” citing only…

    NHTSA complaint #11683017 · source
12. Filed Sep 7, 2024MDOther / UnknownWheels & Tires

    I have only driven my car for 10k miles in past 2 years. I have been on 3 long trips only. Every trip has become scary because one or the other tire turns flat right on busy highways with my little kids in it. I have had one replacement and two repairs on the only long trips I made. No other car I have have had any flat tires till date on the same routes in past 10 years. Tesla vehicles are heavy and they make tires prone to this posing a safety hazard. Tesla should either…

    NHTSA complaint #11613205 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology