2020 Ford Edge engine problems

Related recalls

No recalls on file.

What owners say

1. Filed Oct 6, 2026FLEngine

   The EGR cooler failed (TSB 20-2234) in my 2020 Ford Edge ST line on 9/26/26. I started my car and drove down my street and the car began smoking white/gray burning odor from exhausts with a sudden loss of power while driving on a public street. Leading up to this incident and during, no warning engine inicator lights or ANY notifications appeared. Temperature gauge remained at it's normal operating temp, dead center. The tow and independent mechanic confirmed there was no…

   NHTSA complaint #11769312 · source
2. Filed Oct 5, 2026FLEngine

   The EGR cooler failed on my 2020 Ford Edge ST Line. On 9/26/26, I started my car and it began smoking white/gray from exhausts and burning odor. Leading up to this incident and during, there was no warning indicators or messages regarding the engine that appearerd. The temperature gauge remained at it's normal operating temperature, dead center. \n\nI had the car towed to a local mechanic. They ran diagnostic & codes on the vehicle and threw a P0301code. The mechanic noticed…

   NHTSA complaint #11769012 · source
3. Filed Oct 1, 2026KSEngine

   I have a 2020 Ford Edge Titanium. Only six years old. It has never been wrecked, flooded or had anything else happen to it. I learned today that it needs a completely new transmission due to a torque converter failure and comes at a cost that is higher than the car is now worth. This is unacceptable in a car this age.

   NHTSA complaint #11768374 · source
4. Filed Sep 26, 2026CAEngineSuspension

   Bought car used 4 months ago from Peoria Ford, Glendale. Vehicle overheated on freeway, added coolant- lost all coolant 10 minutes later and white smoke came from exhaust. Ford diagnosed EGR cooler failure, replacement and noted CV joint boot leaking and needed replaced- resulting g on $3200 fix with zero assistance from Dealership or Ford.This issue didn’t happen suddenly after 4 months & we believe it was existing prior to the purchase. Read reports of cooler, coolant/…

   NHTSA complaint #11767105 · source
5. Filed Sep 19, 2026INBrakesEngineTransmission & Drivetrain

   I just bought this vehicle with a broken powertrain, torque converter, and warped rotors. These cars are mechanics special that should only be $2,000. Since it's a 2020 it is being sold for $18,800. It can be repossessed for a crap shoot car. Before this I bought a 2016 Buick Enclave with also a broken torque converter issues. The engineers in car industry have failed. I would rather buy an older pre 2015 mechanics special for $1,200-$2,400, NOT $12,000-$18,800 for a POS…

   NHTSA complaint #11765514 · source
6. Filed Aug 19, 2026GADriver Assistance & Safety TechEngine

   VIn number:[XXX] case number:XXX， My [XXX] car just 6 years old car and just run around 69000 miles，Coolant leaked into the engine, causing it to fail. Ford is demanding we pay ＄6,000 for a replacement.We cant accept we need Pay ＄6000 for replace engine，because Thats problem should don't happened on a 6 Years old car( and just 69000 miles). this issue happened on my car More Than 2 months already ，we don't have a car for drive now，that's so bad. My car send to Mall of…

   NHTSA complaint #11757953 · source
7. Filed Aug 11, 2026KYEngine

   Car stutters, shudders, and hesitates from stopped position. Vehicle does not excelerate smoothly. Safety concern when pulling out into traffic, crossing intersection, or leaving stop. Paducah Ford said it is torque converter and independent mechanic says that as well. Ford issued tech service information concerning shudder for Ford Edge 8F35 transmission and provides a repair procedure for torque converter and output planetary assembly. I am concerned because it may…

   NHTSA complaint #11756196 · source
8. Filed Jul 7, 2026FLEngineTransmission & Drivetrain

   transmission, skipping and shuttering and according to dealership not catching gear occurs during slow speeds. When in drive car will roll backwards and when in reverse car will roll forward. Transmission runs high until gear catches. Engine will then go in to neutral until clutch catches.in according to dealership repair will cost $7000-$11,000. i was told this is unusual. And none of it is covered under warranty

   NHTSA complaint #11748726 · source
9. Filed Jun 23, 2026NMDriver Assistance & Safety TechElectrical SystemEngine

   Complainant: [XXX] Vehicle: 2020 Ford Edge VIN: [XXX] Current Mileage: Approx. 152,000 miles Target of Complaint: Ford Motor Company / [Don Chalmers Ford] Subject: Request for Goodwill Financial Assistance Due to Documented, Inherent Transmission Manufacturing Defect I am filing this dispute to request financial assistance/cost-sharing from Ford Motor Company for a total transmission failure on my 2020 Ford Edge. While the vehicle is past its standard powertrain warranty,…

   NHTSA complaint #11745831 · source
10. Filed Jun 22, 2026KSEngineOther / UnknownTransmission & Drivetrain

    For over a year, engine shudders/jerks when accelerating. I see this has been a repeated complaint by many for a few years now. How is this not a recall?????

    NHTSA complaint #11745654 · source
11. Filed May 4, 2026KYEngine

    Engine died in parking lot, no dashboard lights, smelled sweet, white smoke, dealer said coolant intrusion and engine needs to be replaced

    NHTSA complaint #11735698 · source
12. Filed Mar 23, 2026NVElectrical SystemEngineTransmission & Drivetrain

    Transmission Fluid Leak/Fire Risk (Recall 20S49): Certain 2020 Edge models have missing or loose bolts on the start/stop accumulator endcap, which can cause a leak and increase the risk of fire. Rearview Camera Failure (Recall 20V572000): A common issue where the rear camera may display a blank or distorted image, failing to comply with safety standards. Driveshaft Seizure (Recall 21S43): A potential lack of lubrication in the rear drive unit can cause it to seize, leading…

    NHTSA complaint #11726322 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology