2019 Ford F-350 SD fuel, hybrid & EV propulsion problems

Related recalls

No recalls on file.

What owners say

1. Filed Aug 28, 2026NVFireEngineFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   Wife was driving the truck(I was the passenger) while towing our dump trailer. After approx 100 miles into this trip the dash showed a "Reduced Engine Power Warning", and then shuddered. That was immediately followed by a "Service Engine Soon" warning on the dash, and the truck shut down as we were pulling to the shoulder. I smelled diesel fuel as we slowed to a stop. I got out and saw some smoke coming from under the hood. I looked under the truck and saw burning material…

   NHTSA complaint #11760494 · source
2. Filed Jul 22, 2026120,000 miSDFireTowedEngineFuel, Hybrid & EV Propulsion

   The contact called on behalf of a Federal Agency that owned a 2019 Ford F-350. The contact stated that while driving 55 MPH, the check engine warning light illuminated, and the message "Reduce Power Mode" was displayed. The driver pulled over to the side of the road, and the vehicle shut off. The driver became aware of smoke coming from underneath the hood of the vehicle. The driver opened the hood and became aware that the engine compartment was engulfed in flames. The…

   NHTSA complaint #11752108 · source
3. Filed Jun 26, 2026PAFuel, Hybrid & EV Propulsion

   This model has the same Bosh CP4 high pressure fuel pump as the recalled models 2020-2022 and in fact being older the catastrophic failure risk is higher due to additional mileage. If this part fails the engine shuts off with loss of steering and braking even when pulling 15-20K pounds. The safety concern for this year is the same or greater then newer models.

   NHTSA complaint #11746669 · source
4. Filed Apr 12, 2026IAEngineFuel, Hybrid & EV Propulsion

   While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, It soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then blew off again. I had to replace the entire fuel line at a cost of around $1000. Prior to the first event the filter had been on the truck and was being serviced every other oil change…

   NHTSA complaint #11730641 · source
5. Filed Feb 2, 2026SDFireFuel, Hybrid & EV Propulsion

   Failed component was the upper fuel filter/ fuel filter connecting lines located on top of the 6.7 power stroke engine broke and poured diesel all over the engine and into the valley causing the engine and engine bay to catch on fire while driving down the road. Safety was the fact that our entire truck burnt down and there was extreme risk of loss of life and ended up total loss of property. There have been multiple cases of power strokes from 2011-2026 equipped with the…

   NHTSA complaint #11715122 · source
6. Filed Sep 22, 202544,000 miCAEngineFuel, Hybrid & EV Propulsion

   The contact owns a 2019 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The contact stated that after the vehicle was parked and turned off, there was fuel leaking from the engine compartment. The contact became aware that the fuel line was inoperable, causing fuel to leak onto the engine and the exhaust system. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer…

   NHTSA complaint #11689016 · source
7. Filed Jun 6, 2025UTFuel, Hybrid & EV Propulsion

   The contact owns a 2019 Ford F-350. The contact stated that the vehicle was taken to the dealer to be inspected; however, the dealer refused to inspect the vehicle. The contact related the issue to NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, neither the VIN nor the model year vehicle was included in the recall. No warning lights were illuminated. The manufacturer was made aware of the issue and referred the contact the NHTSA Hotline for assistance. The…

   NHTSA complaint #11665293 · source
8. Filed Mar 21, 2025154,000 miNJFuel, Hybrid & EV Propulsion

   The contact owns a 2019 Ford F-350. The contact stated that while driving at 70 MPH, the vehicle lost motive power. The low fuel pressure warning light was illuminated. The vehicle was started. The vehicle was driven to the shoulder of the roadway. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the vehicle had been to the dealer several times for the failure. In addition, the low-pressure fuel pump was replaced in 2024;…

   NHTSA complaint #11649682 · source
9. Filed Mar 2, 2025FLFuel, Hybrid & EV Propulsion

   The fuel filter housing cracked and started pouring diesel out the top and back of the engine. No warning lights going to dealer for replacement. This can be very dangerous for vehicle occupants and another motorist.

   NHTSA complaint #11645840 · source
10. Filed Feb 26, 2025AZFuel, Hybrid & EV Propulsion

    The CP4 fuel pump failed causing the entire fuel system to be replaced. It is the same pump that is covered in the recall for 2020-2024 6.7 engines.

    NHTSA complaint #11645134 · source
11. Filed Feb 7, 202565,788 miFLFuel, Hybrid & EV Propulsion

    The contact owns a 2019 Ford F-350. The contact stated while routine maintenance was being completed on the vehicle by a certified mechanic, the contact was informed that there were metal shavings inside the fuel pump. The mechanic informed the contact that the fuel pump needed to be replaced. The vehicle had not been repaired. The contact searched online and became aware of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel) and related the failure to the recall. The…

    NHTSA complaint #11641329 · source
12. Filed Jan 30, 2025TXEngineFuel, Hybrid & EV Propulsion

    the CP4 fuel pump sent metal shavings into the fuel injectors and the engine quit. no warning light came on at all. the entire fuel system had to be rebuilt. This happened in the middle of the night on [XXX] in shreveport LA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint #11639694 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology