2007 GMC Sierra 1500 problems, complaints & recalls

2007 GMC Sierra 1500 recalls (2)

• Recall 21V052000Feb 5, 2021557,023 vehicles
  AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

  Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

  Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.

• Recall 21V050000Feb 5, 20212,641,272 vehicles
  AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

  Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

  Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

NHTSA defect investigations

• EA21002Opened Sep 17, 2021Open

  Desiccated Air Bag Inflator Rupture

  From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C…

• EA08010Opened Jun 12, 2008Closed Sep 8, 2008led to recall 08V441000

  Non-crash engine compartment fires

  In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. According to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. This may cause other electrical features…

• PE08010Opened Feb 4, 2008Closed Jun 12, 2008

  Non-crash engine compartment fires

  In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles …

Recent 2007 GMC Sierra 1500 complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Aug 13, 2026COCrash2 injuredTowedAirbagsSeats & Seat BeltsWheels & Tires

   I was in a rollover accident on June 26th 2025 in my boyfriends 2007 GMC Sierra 1500 where we flipped 5 and a half times. The wheel separated from the rim. I will upload photos since I am unsure how to explain how the wheel damage is. During the crash the drivers air bags deployed but the passengers did not. When we finally landed we ended up on the roof. My boyfriend tried to unbuckle my seatbelt but it would not release. He ended up cutting my seatbelt and then at that…

   NHTSA complaint #11756858 · source
2. Filed Mar 25, 2026LAEngine

   Driving on Interstate at a speed of 65, truck lost power. Check engine light and all lights on dash appeared I initially mistakenly reported the wrong mileage of 160k. My vehicle only has 135k miles on it

   NHTSA complaint #11726971 · source
3. Filed Mar 25, 2026LAEngine

   Driving on Interstate at a speed of 70 when truck lost power. Check engine light came on and other lights on dash came on also. 2007 with 160k miles original barely driven. This year should be a part of the Class Action Suit

   NHTSA complaint #11726967 · source
4. Filed Jun 7, 2025LAEngine

   The truck in question has LESS than 163k miles and burn a quart of oil a day, loss of power. There HAS been a recall on this SAME MOTOR 5.3 but while this year was ACKNOWLEDGED it was NOT a part of a recall EXCEPT for passenger side air bag that was replaced at dealership and damaged dash in process. Not it is NON DRIVE ABLE due to oil pressure issues

   NHTSA complaint #11665523 · source
5. Filed May 1, 2025NCEngine

   We were on the highway going 65 mph and all a sudden a long bang happened. After that the anti skid light came on causing the truck to drive hard and lack of power. The engine had a sound that didn’t seam right.

   NHTSA complaint #11658274 · source
6. Filed Sep 19, 2024183,000 miNCElectrical System

   The contact owns a 2007 GMC Sierra 1500. The contact stated while driving approximately 35 MPH, the vehicle independently shut off. The contact stated that there was no warning light illuminated. The contact jiggled the key while it was still in the ignition cylinder and the vehicle restarted. The contact stated that the failure was intermittent but was a recurring failure. The contact stated that the failure was also occurring at various speeds. The contact had taken the…

   NHTSA complaint #11615396 · source
7. Filed Mar 31, 2024CAAirbags

   I was at a stop light and heard a loud noise like a shotgun blast. I felt a concussion hit me in the chest. I thought I had been shot at, then thought I was possibly rear ended but nobody was behind me. I noticed the airbag light was on, the hazards were on and I couldn't shut them off, and the seatbelts were, and still are all locked. But no airbag deployed. There was a smell in the cab that vaguely smelled like a cross between gunpowder and ozone. It's fortunate that I was…

   NHTSA complaint #11580328 · source
8. Filed Dec 29, 2023214,000 miMOCrash2 injuredTowedAirbags

   The contact owns a 2007 GMC Sierra 1500. The contact stated while driving at 65 MPH with his friend in the front passenger's seat, the vehicle crashed into the driver's side of another vehicle that was making a left turn. The air bags failed to deploy. The contact stated that he hit his head against the ceiling, and hit his chest against the steering wheel, which caused him to have tense muscles and nerves. The contact's friend sustained a whiplash and twisted his back. Both…

   NHTSA complaint #11562578 · source

Compare the 2007 GMC Sierra 1500 with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 11, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology