2020 Tesla Model 3 problems, complaints & recalls

2020 Tesla Model 3 recalls (21)

• Recall 26V507000Aug 4, 202620,349 vehicles
  EXTERIOR LIGHTING:HEADLIGHTS

  Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

  Risk: Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.

  Remedy: Tesla Service will replace the headlights, free of charge. Owner notification letters are expected to be mailed October 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.

• Recall 24V935000Dec 17, 2024696,281 vehicles
  TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

  Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

  Risk: Driving with improperly inflated tires increases the risk of a crash.

  Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.

• Recall 24V376000May 28, 2024125,233 vehicles
  SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

  Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Risk: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.

  Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.

• Recall 24V153000Feb 27, 20246,557 vehicles
  ELECTRICAL SYSTEM:SOFTWARE · FORWARD COLLISION AVOIDANCE: WARNINGS:EXTERNAL/PEDESTRIAN ALERT

  Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

  Risk: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.

  Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.

• Recall 24V051000Jan 30, 20242,193,869 vehicles
  ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

  Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

  Risk: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

  Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

• Recall 23V838000Dec 12, 20232,031,220 vehicles
  ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:SOFTWARE

  Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

  Risk: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.

  Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.

• Recall 23V085000Feb 15, 2023362,758 vehicles
  STEERING:AUTOMATED/ADAPTIVE STEERING

  Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation.  The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

  Risk: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.

  Remedy: Tesla will release an over-the-air (OTA) software update, free of charge.  Owner notification letters were mailed April 15, 2023.  Owners may contact Tesla customer service at 1-877-798-3752.  Tesla's number for this recall is SB-23-00-001.

• Recall 22V798000Oct 21, 202224,064 vehicles
  SEAT BELTS:REAR/OTHER:ANCHORAGE

  Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.

  Risk: An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.

  Remedy: Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.

• Recall 22V702000Sep 19, 20221,096,762 vehicles
  VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

  Risk: A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.

  Remedy: Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.

• Recall 22V263000Apr 18, 202248,184 vehicles
  ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

  Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

  Risk: The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.

• Recall 22V235000Apr 12, 2022594,894 vehicles
  ELECTRICAL SYSTEM:SOFTWARE · FORWARD COLLISION AVOIDANCE: WARNINGS:EXTERNAL/PEDESTRIAN ALERT

  Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

  Risk: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

  Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.

• Recall 22V169000Mar 18, 2022947 vehicles
  BACK OVER PREVENTION:DISPLAY FUNCTION

  Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Risk: A delayed rearview camera image reduces the driver's rear view, increasing the risk of a crash.

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.

• Recall 22V063000Feb 4, 2022578,607 vehicles
  ELECTRICAL SYSTEM:SOFTWARE · FORWARD COLLISION AVOIDANCE: WARNINGS:EXTERNAL/PEDESTRIAN ALERT

  Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

  Risk: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

  Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.

• Recall 22V045000Feb 1, 2022817,143 vehicles
  ELECTRICAL SYSTEM:SOFTWARE · SEAT BELTS:FRONT

  Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Risk: The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.

• Recall 22V037000Jan 27, 202253,822 vehicles
  STEERING:AUTOMATED/ADAPTIVE STEERING

  Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

  Risk: Failing to stop at a stop sign can increase the risk of a crash.

  Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.

• Recall 21V00D000Dec 21, 2021356,309 vehicles
  BACK OVER PREVENTION: SENSING SYSTEM: CAMERA · ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK · VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR

  Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.

  Risk: A rearview camera that does not function reduces the driver's rear view, increasing the risk of a crash.

  Remedy: Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.

• Recall 21V846000Oct 29, 202111,728 vehicles
  FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING · FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA · FORWARD COLLISION AVOIDANCE:SOFTWARE · FORWARD COLLISION AVOIDANCE: WARNINGS

  Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.

  Risk: Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.

  Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.

• Recall 21V834000Oct 25, 20213 vehicles
  AIR BAGS:SIDE/WINDOW:CURTAIN

  Tesla, Inc. (Tesla) is recalling certain 2020-2021, 2023 Model 3 vehicles. The left and/or right side curtain air bag may have been improperly secured to the roof rail, which could result in a twisted air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 226, "Ejection Mitigation."

  Risk: A twisted side curtain air bag may improperly deploy, increasing the risk of injury or occupant ejection during a crash.

  Remedy: Tesla Service will inspect and realign the left and right side curtain air bag as necessary, free of charge. Owner notification letters were mailed December 23, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-20-006.

• Recall 21V835000Oct 25, 20212,791 vehicles
  SUSPENSION:CRITICAL FASTENERS · SUSPENSION:FRONT

  Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.

  Risk: A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.

  Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.

• Recall 21V389000May 25, 20215,530 vehicles
  SEAT BELTS · SEAT BELTS:CRITICAL FASTENERS

  Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.

  Risk: An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.

  Remedy: Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.

• Recall 21V387000May 25, 20215,974 vehicles
  SERVICE BRAKES, HYDRAULIC:CRITICAL FASTENERS · SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

  Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.

  Risk: Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.

  Remedy: Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.

NHTSA defect investigations

• PE26006Opened Jul 29, 2026Open

  Lower Lateral Link detachment

  The Office of Defects Investigation (ODI) has received 156 complaints alleging a suspension failure in model year (MY) 2018-2020 Model 3 and MY 2021-2023 Model Y vehicles. The suspension failure involves the detachment of the front lower lateral link, which potentially causes a loss of vehicle directional control. In most cases, there was no advance warning or indication that the suspension failure would occur.  Some cases cite noises occurring prior to failure, but note that the vehicle provides no visual warnings. Once the failure occurs, the vehicle may not be drivable, thus requiring a tow…

• EA26002Opened Mar 18, 2026Open

  FSD Collisions in Reduced Roadway Visibility Conditions

  The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates or modifications by Tesla to the degradation detection system, including the timing, purpose, and ca…

• PE25012Opened Oct 7, 2025Open

  Traffic safety violations while Full Self Driving ("FSD") is engaged

  The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 partial automation systems are designed to support and assist the driver in performing certain aspects …

• AQ25002Opened Aug 20, 2025Open

  Compliance with Standing General Order 2021-01 Reporting Requirements

  The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority of these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of Tesla receiving notice of the crash. When the reports were submitted, Tesla submitted them in one of two ways. Many of the reports were submitted as part of a si…

• PE24033Opened Jan 6, 2025Closed Apr 3, 2026

  Actually Smart Summon sessions resulting in low-speed impacts.

  On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user from a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla as well as complaints submitted to ODI from consumers to identify Summon incidents resulting in crashes. ODI's analysis indicates that almost all Sum…

• PE24031Opened Oct 17, 2024Closed Mar 18, 2026

  FSD Collisions in Reduced Roadway Visibility Conditions

  On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SGO-reported crashes identified in the opening document, and if so, the contributing circumstances for each of those crashes; and any updates or modificatio…

• RQ24009Opened Apr 25, 2024Open

  Recall 23V838 Remedy Effectiveness

  The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise Control (TACC) and Autosteer. In describing the safety defect, Tesla’s Defect Information Report (DIR) explained that “the prominence and scope of the …

• DP23002Opened Jun 29, 2023Open

  Sudden Unintended Acceleration

  The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petitioner bases this information on a review of open-source research and the DP20-001 denial. The petition and related materials can be reviewed at NHTSA.gov under the following ODI number: 11528471.

• DP23001Opened Apr 7, 2023Closed Mar 18, 2026

  Defect Petition Interlock Request

  On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petition is a paper authored by Petitioner. According to Petitioner, the differences in the operator controls between the subject Tesla vehicles and internal combustion engine powered vehicles promote driver pedal misapplication, leading to sudden unintended acceleration (SUA) incidents. To fix this alleged de…

• DP22005Opened Jan 27, 2023Closed Aug 7, 2023led to recall 22V063000

  Pedestrian alert sounds

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc…

• EA22002Opened Jun 8, 2022Closed Apr 25, 2024led to recall 23V085

  Autopilot System Driver Controls

  The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support this work, ODI collected additional crash information and assessed vehicle control authority, driver engagement technologies, and related human factors considerations associated with partial automation …

• PE22002Opened Feb 16, 2022Closed Jun 29, 2026

  Unexpected Brake Activation

  On February 16, 2022, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE22002) to investigate reports of unexpected deceleration while driving with the adaptive cruise control system engaged in Model Year (MY) 2021 – 2022 Model 3 and Model Y vehicles manufactured by Tesla. The subject systems include Autopilot (all versions), Full Self-Driving (FSD) and Traffic Aware Cruise Control (TACC). These complaints have been colloquially referred to as “phantom braking”. ODI opened PE22002 to determine the scope and severity of the potential problem and to assess any resultin…

• PE21023Opened Dec 21, 2021Closed May 26, 2023

  Tesla Passenger Play

  The Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE21-023) on December 21, 2021, to evaluate the driver distraction potential and use frequency / circumstances of in-vehicle game-play functionality referred to as ?Passenger Play? in certain model year (MY) 2017-2022 Tesla Model 3, S, X, and Y vehicles. Distracted driving can result in an increased risk of a crash. PE21-023 was prompted by the receipt of Vehicle Owners Questionnaire (VOQ) 11439598 from the owner of a 2021 Model 3 on November 6, 2021. ODI sent an Information Request (IR) letter to Tesla on January 20, 202…

• PE21020Opened Aug 13, 2021Closed Jun 8, 2022

  Autopilot & First Responder Scenes

  On August 13, 2021, NHTSA?s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE21-020) to assess the performance of Tesla?s Autopilot system (a system characterized by Tesla as an SAE Level 2 driving automation system designed to support and assist the driver in performing the driving task) available in Tesla vehicles. The investigation opening was motivated by an accumulation of crashes in which Tesla vehicles, operating with Autopilot engaged, struck stationary in-road or roadside first responder vehicles tending to pre-existing collision scenes. Upon opening the invest…

NHTSA 5-Star safety ratings

Recent 2020 Tesla Model 3 complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Sep 16, 2026CASteering

   The steering assist reduced alert popped up on the tesla screen. While attempting to turn into a parking garage, a "steering assist reduced" alert suddenly appeared on the tesla screen, and the steering wheel locked up/became extremely heavy and unable to steer left or right. Because the steering assist failed in active traffic at the entrance, the vehicle was temporarily stranded, exposing to oncoming traffic and created an immediate risk. Failed component: electronic…

   NHTSA complaint #11764589 · source
2. Filed Sep 10, 2026WASuspension

   Lower Lateral Link Fronts and front lower compliance link assembly for both right and left. There have apparently been on going issues for the Tesla Model 3 suspension links. I first started hearing noises from the suspension last month, I was booked for a weekend service and then rescheduled for today. I stopped by for a formal comprehensive inspection and was informed that there is tearing in the suspension. I already had this vehicle brought in for warranty earlier this…

   NHTSA complaint #11763382 · source
3. Filed Sep 7, 2026VASuspension

   I own a 2020 Tesla Model 3. Over approximately the past 2–3 weeks, the vehicle has developed a noticeable rattle/creaking noise coming from the left-front suspension area. The noise was not previously present and appears to be getting my attention as a potential suspension-related safety issue. I am concerned because my vehicle falls within the model-year range of Tesla Model 3 vehicles associated with reported front suspension/lateral-link issues. I understand NHTSA is…

   NHTSA complaint #11762629 · source
4. Filed Sep 3, 2026119,730 miNJCrash2 injuredTowedAirbagsBrakes

   The contact owned a 2020 Tesla Model 3. The contact stated that while driving 50 MPH in traffic on a sunny day, the vehicle drove over a pothole, and the traction control and ABS warning lights illuminated. The brake pedal was checked; however, fifteen minutes later the vehicle crashed into a 26-foot box truck. The contact stated that the box truck left the scene of the crash. The tire skid marks were 100 feet long. The air bags failed to deploy. The contact stated there was…

   NHTSA complaint #11761825 · source
5. Filed Aug 17, 202680,000 miCAElectrical System

   The contact owns a 2020 Tesla Model 3. The contact stated that while driving at an undisclosed speed, the safety features independently deactivated. The contact purchased and replaced the battery. The vehicle was taken to the dealer, where it was diagnosed with ECU failure. The contact was informed that the ECU needed to be replaced. The vehicle was not repaired. The contact stated that an unknown software update was completed in June 2026. In addition, the contact stated…

   NHTSA complaint #11757430 · source
6. Filed Aug 16, 2026CABody & Structure

   The front passenger door intermittently becomes “unclosed.” When this occurs, the vehicle displays “door open” and the passenger door window rolls down and up repeatedly. The window cycling continues until the door is slammed firmly shut. Once the door is securely shut, the window cycling stops and the door-open warning clears. When it occurs: The issue began in the second week of August while a passenger was in the front seat. It continued while the passenger remained…

   NHTSA complaint #11757329 · source
7. Filed Aug 11, 2026NYSuspension

   I was told my car is unsafe to drive after taking it to the mechanic for a routine tire balance and rotation. I currently need both rear control arms replaced. I had them replaced in the past. In addition, I have had the front control arms replaced more than once, the lower lateral links replaced, numerous hubs repaired, forelinks and knuckles all replaced not too long ago, so this news comes as a shock. The first control arm failure occurred when the car was only a year and…

   NHTSA complaint #11756378 · source
8. Filed Aug 6, 2026CACrashTowedElectrical System

   I was operating my Tesla with Full Self-Driving (FSD) engaged when the incident occurred. I was turning right onto [XXX] from [XXX] and was positioned in the left right-turn lane approaching a railroad crossing. The railroad crossing gates were already fully lowered, indicating an approaching train. Despite the lowered crossing gates, the vehicle accelerated forward into the crossing rather than stopping. The vehicle drove through the lowered crossing gate, which struck and…

   NHTSA complaint #11755168 · source

Compare the 2020 Tesla Model 3 with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology