2019 Tesla Model X suspension problems

Related recalls

No recalls on file.

What owners say

1. Filed Apr 7, 2026CASuspensionWheels & Tires

   On March 6, 2026, at 7:15 PM, the rear lower control arm on my 2019 Tesla Model X Raven catastrophically failed while traveling at 55 mph. The suspension component snapped without warning or impact, causing an immediate and dangerous loss of vehicle stability with my children inside. I was forced to perform an emergency stop on the narrow shoulder of US-395, an unlit one-lane highway with a 65-mph speed limit. Because the vehicle was disabled in a remote, dark area, my…

   NHTSA complaint #11729585 · source
2. Filed Mar 31, 2026ILSteeringSuspensionWheels & Tires

   I have replaced several sets of tires with this Tesla Model X 2019. After years of dealing with a front end alignment problem, I finally had the repair done with some assistance from Tesla. When I purchased my vehicle under warranty, I reported problems with steering and pulling to one side, but they repeatedly claimed they couldn't replicate. This was before they allowed customers to drive with the repaid team. I mention the front-end problems as that has coupled with the…

   NHTSA complaint #11728414 · source
3. Filed Mar 3, 2026VASuspension

   Vehicle: 2019 Tesla Model X VIN: [XXX] Component: Suspension/Steering/Drivetrain Defect Description: Three concurrent Technical Service Bulletin failures: 1. TSB SB-21-39-001: Front drive unit halfshafts premature failure (manufacturing defect, pre-May 2019 builds) 2. TSB SB-20-32-004: Steering intermediate shaft corrosion due to inadequate road contaminant protection (design defect) 3. Ball joint/control arm water ingress from inadequate sealing (design defect) All three…

   NHTSA complaint #11721870 · source
4. Filed Apr 29, 2025WASuspension

   I got my suspension replaced on my 2019 Model X (that I bought used from Tesla directly) in June 2023. Tesla was suppose to do a through 140 point inspection before putting the car for sale on their website but after less than 2 years and 15000 miles (after the suspension was replaced). The same suspension same issue came up. Tesla told me that they need to replace the suspension again and will bill me $2100. I have owned multiple cars but I have not have to replace…

   NHTSA complaint #11657481 · source
5. Filed Nov 22, 2024CASuspension

   To Whom It May Concern, Service bulletin SB-21-39-001 [XXX] ) was issued for the front half shaft repair for model X, S. In my case, the repair work was done but did not address the issue. They only replaced the parts, and after two years the problem still occurs: vibrations at accelerations, etc. I had to pay over $2000 for the same work, which will probably not address the issue in the permanent matter. Tesla, especially, Model Xs has issues with front half shafts, and I…

   NHTSA complaint #11626897 · source
6. Filed Nov 5, 2024CASuspension

   The suspension is making loud clicking noises when turning or accelerating. The suspension system seems to have an inbuilt design flaw as many people are reporting the issue online.

   NHTSA complaint #11623713 · source
7. Filed Feb 15, 2024COOther / UnknownSteeringSuspension

   I was just out of warranty and have a VERY loud squeaky noise when I turn my wheel. I was told that because of the weight of the battery, this can happen. I was told it was not an expensive fix but now they say it's $3,000. It is a known issue and the engineers didn't build to hold the car up properly with the weight of the battery. May be a potential hazard and I don't feel safe driving it and also hard to drive as loud as it is. If they are aware and have since fixed this…

   NHTSA complaint #11572153 · source
8. Filed Jan 13, 2024CASuspension

   Hello, It's [XXX] again. This Tesla has just showed up in the junkyard. [XXX] It has not been in a crash, the back wheel and suspension have simply wrenched themselves off. Information from within Tesla proves that these suspension defects have been known about by Tesla for many years but rather than fix the problems they are covering it up and blaming the owners. [XXX] Proof of this can be found here [XXX] The VW "scandal" involved VW covering up slightly smelly exhaust…

   NHTSA complaint #11565387 · source
9. Filed Sep 8, 202355,482 miMDDriver Assistance & Safety TechElectrical SystemSuspension

   The contact owns a 2019 Tesla Model X. The contact stated that while turning the steering wheel, there was an abnormal sound coming from the front end near the tires and wheel wells. There was a vibration in the front end of the vehicle while driving. The Autopilot feature became inoperable. The "Autopilot camera unavailable" message was displayed. While driving, the instrument cluster went dark. The vehicle was taken to the local dealer, where it was diagnosed that the…

   NHTSA complaint #11543337 · source
10. Filed Mar 14, 2023CACrashTowedSuspensionWheels & Tires

    At the low speed, the car suspension failed (most likely the control arm) and the vehicle swung to the right and crashed into the car bridge rails. As a result of this, the right front wheel dislodged completely, which would not be possible if there were no mechanical problems with the suspension. Tesla Dublin had worked on my suspension three weeks prior to the accident. The full video from the dash cam before and after the accident is available below.…

    NHTSA complaint #11511871 · source
11. Filed Jan 16, 2023FLSuspension

    Front Half shafts keep failing due to extreme angles of operation where bearing races are spalled as a result and could result in a high speed failure. Have had 3 replacements in 25K miles and will need a 4th replacement. Lowering car to bring halfshafts more geometrically in line improves halfshaft life, but in turn cause significant rear tire wear resulting in potential high speed blow outs. Adjustable suspension Front and rear links would significantly improve both issues…

    NHTSA complaint #11501942 · source
12. Filed Jan 10, 2023NJSteeringSuspensionWheels & Tires

    Constant shudder when driving because of design flaw in Camber & control arms. We tried reaching out to Tesla multiple times but they don't want to cover it under warranty Multiple owners are having same issue

    NHTSA complaint #11501107 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology