2026 Tesla Model Y suspension problems

Related recalls

• Recall 26V558000Aug 31, 202619 vehicles
  SUSPENSION:CRITICAL FASTENERS · SUSPENSION:FRONT

  Tesla, Inc. (Tesla) is recalling certain 2026 Model Y vehicles. One or more front suspension lateral link fasteners may not have been properly tightened, allowing the lateral link to loosen or separate from the sub-frame.

  Risk: A lateral link separation could shift the wheel alignment, causing a loss of vehicle control and increasing the risk of a crash.

  Remedy: Tesla Service will tighten or replace the fasteners and check wheel the alignment, free of charge. In addition, Tesla Service will replace any related parts that may have been damaged as necessary. Owner notification letters are expected to be mailed October 30, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-31-004.

What owners say

1. Filed Oct 7, 2026WASteeringSuspension

   Cut to 1,423 characters — fits with room to spare. Same facts, same careful framing, nothing lost. I'm reporting a recurring suspension/control-arm problem with 2026 Tesla vehicles. My 2026 Tesla developed suspension squeaking. Tesla fixed it under warranty. The same noise is back. While Tesla had my vehicle, they gave me a 2026 Model Y loaner — it makes the same noise. The problem is in multiple 2026 vehicles, not just mine. Tesla Service Bulletin SB-25-31-005 (May 8, 2026)…

   NHTSA complaint #11769629 · source
2. Filed Aug 8, 2026TXSuspensionWheels & Tires

   Tesla was in FSD and had the latest software update installed on 8/6/28 which included the new FSD version released. On 8/7/28 on the way to work that my wife takes every time she goes to work the FSD ran over a large pot hole which it had never done before on the previous FSD version. The car started having rattling of the steering wheel and a rattling noise from over the rear driver wheel area. The next available Tesla service appointment was on 8/27 but we walked in and…

   NHTSA complaint #11755680 · source
3. Filed Jul 1, 2026NCSteeringSuspensionWheels & Tires

   Steering wheel vibration occurs at highway speeds between 70 and 75 mph on a 2026 Model Y with under 1,000 miles at time of complaint. The vibration was reported to the dealer, who performed a tire balance and alignment check and confirmed both were within specification. The vehicle was tested by the dealer during a service ride-along and no vibration was detected by the technician. However, vibration was independently confirmed by the owner in a same-model loaner vehicle on…

   NHTSA complaint #11747655 · source
4. Filed May 29, 2026FLBrakesSuspension

   Service Concern — Front Suspension / Rattling Noise Vehicle is experiencing a persistent rattling/knocking noise from the front area when driving over bumps, uneven pavement, or rough roads. Noise is noticeable at low to moderate speeds and appears suspension-related. Condition seems consistent with known Tesla Model Y service concerns regarding: * front upper control arm mounts, * front damper assemblies, * and wiper bracket pencil braces. Requesting inspection and…

   NHTSA complaint #11740760 · source
5. Filed May 27, 2026CACrashTowedElectrical SystemOther / UnknownSuspension

   Tesla 2026 Model Y was involved in a severe motor vehicle accident directly caused by a critical software and/or hardware malfunction of Tesla’s Full Self-Driving (FSD) system. At the time of the incident, the vehicle’s Full Self-Driving (Supervised) software suite was actively engaged and driving the vehicle. While navigating, the system suffered an abrupt and uncommented control malfunction. Despite prompt attention, the autonomous system executed an erratic, uncorrectable…

   NHTSA complaint #11740400 · source
6. Filed May 26, 2026FLSuspension

   Service Concern — Front Suspension / Rattling Noise Vehicle is experiencing a persistent rattling/knocking noise from the front area when driving over bumps, uneven pavement, or rough roads. Noise is noticeable at low to moderate speeds and appears suspension-related. Condition seems consistent with known Tesla Model Y service concerns regarding: * front upper control arm mounts, * front damper assemblies, * and wiper bracket pencil braces. Requesting inspection and…

   NHTSA complaint #11740003 · source
7. Filed May 22, 2026MISuspension

   The car is unstable on the highway when there is a crosswind - either from wind gusts or from large vehicles. The car is easily pushed by wind until lane assist activates to stop it from going outside of the lane. It feels very unsafe to drive on the highway. This is how the car was when it was bought. An alignment was done during the first Tesla service visit and that helped slightly. The second Tesla service visit they said the vehicle was operating as expected and then…

   NHTSA complaint #11739597 · source
8. Filed May 16, 2026TXOther / UnknownSteeringSuspension

   2025/2026 Tesla Model Y Juniper experiences noticeable vibration starting at approximately 75 mph on smooth highways. The vibration is felt throughout the entire vehicle: steering wheel, doors, seats, and pedals/floor. It is not limited to the steering wheel. Tire balancing, alignment, and foam checks have all been performed with no resolution. Tesla service states the issue is ‘normal/within spec.’ Video of the vibration with speedometer visible is attached. This matches a…

   NHTSA complaint #11738360 · source
9. Filed Mar 14, 2026GASteeringSuspension

   I am reporting a suspected defect involving the front suspension or steering system of my Tesla Model Y. The vehicle produces loud popping, knocking, and rattling noises from the front end when turning the steering wheel at low speeds, particularly as the steering approaches full lock in either direction. The noise appears to originate from the front suspension or steering components and occurs consistently during normal operation. This issue raises concerns about potential…

   NHTSA complaint #11724354 · source
10. Filed Mar 13, 2026CASuspension

    I am filing a complaint regarding a suspension defect on my new Tesla Model Y Juniper. Shortly after purchasing the vehicle, I began hearing a distinct knocking / clunking noise coming from the suspension when driving over small road imperfections and at low speeds. The noise is clearly abnormal for a new vehicle and sounds like loose or defective suspension components. I brought the vehicle to a Tesla service center, but the issue has not been resolved. Despite inspection…

    NHTSA complaint #11724197 · source
11. Filed Mar 10, 2026ILSuspension

    Brand new car and its widely reported of front suspension noise, particularly with the RWD models. My car is the RWD model and I have the distinct and noticeable front suspension noise at non highway speeds.

    NHTSA complaint #11723277 · source
12. Filed Mar 5, 2026OKBrakesSeats & Seat BeltsSuspension

    1. There is a constant thunking noise coming from the front suspension when traveling on slightly bumpy roads at low speeds. 2. Both front seats squeak and squeal as if they are loose and not bolted in correctly. 3. Front brakes screach and squeal when coming to a stop in cold or wet weather, escpecially pronounced during cold weather. (This is an active service bulletin in all vehicles made in their Berlin factory but is happening in U.S. built vehicles as well.

    NHTSA complaint #11722218 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology