2011 Audi Q5 problems, complaints & recalls

2011 Audi Q5 recalls (5)

• Recall 18V818000Nov 19, 20185,987 vehicles
  FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.

  Risk: The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.

  Remedy: Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.

• Recall 18V082000Jan 30, 2018162,782 vehicles
  AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

  Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2006-2013 Audi A3, 2007-2009 A4 Cabriolet and S4 Cabriolet, 2008 RS4 Cabriolet, 2009-2012 Q5, and 2010-2012 Audi A5 Cabriolet and S5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

  Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

  Remedy: Audi will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began February 23, 2018. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 69R6. Note: This recall partially supersedes recall 16V-078.

• Recall 17V001000Jan 3, 2017234,057 vehicles
  AIR BAGS:SIDE/WINDOW · VISIBILITY:SUN/MOON ROOF ASSEMBLY

  Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2011-2017 Audi Q5 vehicles. The sunroof drainage system may allow water to soak into the foam surrounding the side head air bag inflator canister resulting in the corrosion of the canister. If this happens, the corrosion can weaken the canister and the inflator could fracture without air bag deployment, propelling fragments into the passenger compartment, striking and causing serious injury to vehicle occupants.

  Risk: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.

  Remedy: Audi will notify owners, and dealers will inspect the inflator and either coat it or replace it, as necessary, after removing the surrounding foam, free of charge. The recall is expected to began March 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69P1.

• Recall 16V660000Sep 13, 2016143,214 vehicles
  FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.

  Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

  Remedy: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20W9.

• Recall 16V078000Feb 10, 2016659,493 vehicles
  AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

  Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

  Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

  Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.

Recent 2011 Audi Q5 complaints

Excerpts of the newest owner complaints, lightly cleaned of personal details. Complaints are unverified owner reports.

1. Filed Aug 25, 2026TXSuspension

   1) The rear structural subframe (crossmember) has completely rotted, perforated, and failed due to severe corrosion. The factory-installed plastic underbody rock shields trapped road salt and water, causing the frame to rust from the inside out. The corrosion has spread, completely fusing and compromising the rear suspension mounting points and the rear differential brackets. The vehicle is fully available for physical inspection upon request. 2) My safety and the safety of…

   NHTSA complaint #11759438 · source
2. Filed Aug 5, 2026MASuspension

   During an inspection of my 2011 Audi Q5 at Audi Burlington, severe corrosion was discovered on the rear subframe, which supports rear suspension components. The corrosion was substantially worse than normal surface rust and may compromise the structural integrity of the subframe and suspension mounting points. The condition was not readily visible during ordinary vehicle use because portions of the subframe are covered. The vehicle has been operated in the northeastern…

   NHTSA complaint #11755002 · source
3. Filed Apr 17, 2025NHSuspension

   Rear subframe rust causing car to fail state inspection. This vehicle has been maintained well and always parked in garage. The rear subframe rusted most, then front subframe. This is a common compliant among Audi forum users.

   NHTSA complaint #11655321 · source
4. Filed Apr 13, 2025CAElectrical System

   Rear driver side door will not unlock when keypad, nor inside unlock button is pressed. Once inside, door will not unlock in sequence with other doors when vehicle is shut off and it is time to exit the vehicle.

   NHTSA complaint #11654307 · source
5. Filed Jan 18, 2025IAElectrical SystemEngineFuel, Hybrid & EV Propulsion

   Audi q5 shows no recalls on my vehicle. My car stops randomly while driving even while being on highways and interstates. As well as the passenger side leaking due to sunroof drainage coming to the inside (which may affect the air bags). This Car has not had any repairs on recalls that I know of personally.

   NHTSA complaint #11636788 · source
6. Filed Nov 4, 2022CAFuel, Hybrid & EV Propulsion

   The contact's wife owns a 2011 Audi Q5. The contact stated that after he parked the vehicle in his garage, he smelled a fuel odor outside of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the flange had cracked and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and advise the contact to call the manufacturer. The manufacturer was notified of the failure and the…

   NHTSA complaint #11492317 · source
7. Filed Aug 25, 2022CAEngineFuel, Hybrid & EV Propulsion

   Audi offered a warranty extension for intake manifold & fuel injectors in certain 2008-2011 Model Year Audi Vehicles with 2.0 TFSI Engine. Audi rejected our claim for a faulty fuel injector in our 2011 car citing that “vehicle does not have the extended warranty for fuel injectors and the information that was submitted was only for 2.0 TFSI Engine's with the Engine code of CBFA & CCTA. The engine in your vehicle is a 3.2 FSI with the Engine code CALB. So this warranty…

   NHTSA complaint #11481103 · source
8. Filed May 20, 2022NHOther / Unknown

   During a routine inspection my mechanic noticed the subframe of my 2011 Audi Q5 was rusted through in numerous spots. It seemed odd that a vehicle bought new and garaged since it was purchased had such extensive rust. Pictures of the rusted subframe were taken and shown to the local Audi dealer. The dealer then asked to bring the vehicle in so they could take their own pictures. Contacted Audi NA and spoke with rep about problem. The phone call ended abruptly when the Audi…

   NHTSA complaint #11465454 · source

Compare the 2011 Audi Q5 with another vehicle →

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data, as of Oct 10, 2026. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology