2018 Tesla Model 3 steering problems

Related recalls

• Recall 23V085000Feb 15, 2023362,758 vehicles
  STEERING:AUTOMATED/ADAPTIVE STEERING

  Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation.  The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

  Risk: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.

  Remedy: Tesla will release an over-the-air (OTA) software update, free of charge.  Owner notification letters were mailed April 15, 2023.  Owners may contact Tesla customer service at 1-877-798-3752.  Tesla's number for this recall is SB-23-00-001.

• Recall 22V037000Jan 27, 202253,822 vehicles
  STEERING:AUTOMATED/ADAPTIVE STEERING

  Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

  Risk: Failing to stop at a stop sign can increase the risk of a crash.

  Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.

What owners say

1. Filed Sep 15, 202681,000 miCATowedSteering

   The contact owns a 2018 Tesla Model 3. The contact stated that while driving 4 MPH, the front sway bar detached from the vehicle, and the contact lost steering control. The vehicle was towed, and a service center was contacted but informed the contact that the repair was not covered because the VIN was not included in a recall associated with the failure. The failure mileage was approximately 81,000.

   NHTSA complaint #11764522 · source
2. Filed Aug 31, 2026CASteeringSuspension

   This is a follow-up to a previously submitted complaint regarding the same issue. I am submitting this update to reference NHTSA's recently opened investigation into 2018-2019 Tesla Model 3 suspension failures. Previous complaint ID is 11732882.

   NHTSA complaint #11761140 · source
3. Filed Aug 1, 2026ORSteeringSuspension

   Concern: Suspension Noise - What location is the noise coming from? Front. Suspension or Steering. What best describes the issue? Noise from suspension when driving on uneven roads. Repair Notes: Inspected Front Suspension for Activity 01 (Front suspension noise). Found torn bushings on Front Lateral Links and Compliance Links. Heavily torn on LH side. Safety concern. Both LH and RH Front Lower Compliance link and Lateral Links replacement recommended. Wheel alignment…

   NHTSA complaint #11754213 · source
4. Filed Jul 31, 202676,000 miCATowedSteeringSuspension

   The contact owns a 2018 Tesla Model 3. The contact stated that while driving at an undisclosed speed, the vehicle was shaking uncontrollably. The contact pulled over and had the vehicle towed to the dealer. The dealer determined that the front control arm had detached from the front passenger’s side wheel. The dealer replaced the front control arm, lateral link, and steering column. The contact stated that there was no impact to the vehicle to have caused the failure. The…

   NHTSA complaint #11754042 · source
5. Filed May 23, 2026NHSteering

   After an over the air software update this past week 2026.14.6 my Tesla Model 3 power steering has failed. EPAS shows ACTICE in service mode, calibration was successfully completed and there are no active EPAS/rack faults. Power steering assists at higher speeds but fails below 20mph. Tesla has a history of steering related software problems and needs to take ownership of the problem.

   NHTSA complaint #11739674 · source
6. Filed May 8, 2026OKSteeringSuspension

   The control arms on all make and models of tesla have a horrible design that all water off of the car flows down the sides of the front hood and down onto the control arm bushing. This could be a simple fix for tesla to out a boot on it to cover the bushing. The control arms start to fail at any given time. This is costing owners thousands of dollars. I have had to had them replace once under warranty and now they want me to pay 2000 since I am out of warranty. Owners with…

   NHTSA complaint #11736641 · source
7. Filed May 7, 2026LAAirbagsSteering

   Within the last 7 days, my 2018 Tesla Model 3 Long Range AWD began displaying active alerts for two separate safety system failures: (1) alert code UI_a020 / GTW_w075 — Steering Assist Reduced, stating steering may require increased effort, and (2) alert code RCM_a056 — Front Passenger Safety Restraint System Issue, requiring service. The steering alert appeared intermittently, firing at consistent times of day suggesting a possible electrical or sensor fault rather than…

   NHTSA complaint #11736370 · source
8. Filed Apr 21, 2026CABody & StructureSteeringSuspension

   The front lateral links, compliance links, and stabilizer bar link on my 2018 Tesla Model 3 Long Range failed and required replacement in January 2026. Prior to failure, abnormal creaking and clunking noise from the front suspension began appearing weeks before the repair — no warning lights illuminated at any point. The failed components were replaced by a Tesla-certified Service Center and are no longer available for inspection. The failure was confirmed and repaired…

   NHTSA complaint #11732882 · source
9. Filed Feb 26, 2026CASteeringSuspension

   The front lower lateral link (rearward lower control arm) fastener/bolt completely backed out and fell off the vehicle while in motion, causing the lateral link to separate entirely from the subframe. This is the exact mechanical failure described in Tesla Recall Campaign 23V-235 (Service Bulletin SB-23-31-001), however, my specific VIN was not included in that recall. The vehicle and components are currently at an independent EV repair facility and are available for…

   NHTSA complaint #11720800 · source
10. Filed Jan 30, 2026PASteeringSuspension

    The front control arms are creaking and I’ve read that many of models built in 2018 have this problem as well. It is unknown if it is a safety concern or not.

    NHTSA complaint #11714500 · source
11. Filed Dec 17, 2025CASteeringSuspension

    The front suspension control arm was completely detached due to unfastened bolts. While this happened on the parking lot at low speed, such detachment at highway speed would certainly lead to major damage, loss of control and injuries or death to the driver. Pictures attached show that the bolts did not have any thread lock applied and simply unscrewed themselves due to vibration. The vehicle was brought to Tesla service, where the owner was charged $3700 for repairs. The…

    NHTSA complaint #11705487 · source
12. Filed Nov 20, 2025NJAcceleration & Cruise ControlSteering

    I am reporting a major safety defect that began immediately after Tesla installed the Full Self-Driving (FSD) hardware upgrade on my vehicle. After paying $2,000 for FSD and receiving the hardware retrofit, the car now instantly veers left toward oncoming traffic whenever FSD is engaged. This began immediately after Tesla’s installation. Before this service, my vehicle operated safely. I have contacted Tesla Cherry Hill Service Center in New Jersey multiple times. The…

    NHTSA complaint #11700524 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology