2016 Ford F-150 electrical system problems

Related recalls

No recalls on file.

What owners say

1. Filed Sep 15, 2026WAElectrical SystemLightingVisibility & Wipers

   The body control module was destroyed when water leaked on it. Apparently there is a failed windshield seal(maybe) that causes leaking down the A pillar. That pillar leads the water directly to the wiring harness for the BCM. When my BCM went out, wipers, blinkers, external lights, speedo/tach, power windows (in the front), all HUD, all stereo, and I think the security system too, stopped working. It was raining hard, it was a very dark day/difficult to see. I and others…

   NHTSA complaint #11764520 · source
2. Filed Sep 2, 2026MNElectrical SystemTransmission & Drivetrain

   I would like to file complaint against Ford for their latest recall (26N041) and how they are not doing replacing the defective Lead Frame in customers vehicles. It's a big scam and a waste of time. I brought my 2016 Ford F-150 in for Ford’s latest recall (26N04) affecting 2015–2017 models due to the transmission leadframe issue. I explained that I’ve been dealing with an intermittent problem for the past seven months: while driving, the gear indicator lights on the dash…

   NHTSA complaint #11761760 · source
3. Filed Aug 19, 2026NCFireElectrical SystemLightingVisibility & Wipers

   This vehicle 2016 ford F150 is known to have shorting issues. From literally all wiring harnesses. I had a small fire in my truck due to this issue, caused melting of the ribbon cable in my seat heater control module, which is a known issue from Ford. I have shorting in my turn signal switch (no wipers). Is that safe? I am a research scientist and engineer, I can tell you now it is not safe. If i need to prove it, I can do so with ease and write the necessary literature. If…

   NHTSA complaint #11757955 · source
4. Filed Aug 11, 2026OKElectrical SystemAcceleration & Cruise ControlTransmission & Drivetrain

   I was at my granddaughters and I went to leave and it was like dead except the wrench came up in the dash panel , I waited before calling my husband and I went back to try and start it again and it started no wrench in the display or anything , this was in February 2026. In March of 2026 I was in the middle turn lane on [XXX] by Tuttle, Ok. And it stalled as I was trying to turn and would not move I put it back into park and then back to drive and it turned . Next incident…

   NHTSA complaint #11756379 · source
5. Filed Aug 9, 2026OHCrashElectrical SystemOther / Unknown

   Back up camera malfunctioned, not showing there was a smaller car behind me in my own driveway. Backing up into my driveway at night, it did not pick up or show the smaller car which I back up into, causing $2890 in damages which I had to pay for.

   NHTSA complaint #11755785 · source
6. Filed Jul 2, 2026141,000 miCAFire1 injuredTowedElectrical System

   The contact owned a 2016 Ford F-150. The contact stated that while driving 70 MPH on the freeway, another vehicle driver pulled beside the contact on the front passenger’s side of the vehicle, and informed the contact that there was smoke coming from the vehicle, and the contact became aware of smoke coming from the rear passenger’s side seats. No warning light was illuminated. The contact pulled over to the right side of the road, turned off, and then exited the vehicle.…

   NHTSA complaint #11747960 · source
7. Filed Jun 18, 2026FLElectrical SystemFuel, Hybrid & EV PropulsionTransmission & Drivetrain

   My 2016 Ford F-150 (VIN [XXX]) experienced an intermittent failure involving the transmission range sensor system. While driving, the vehicle displayed a check engine light and a “See Service Manual” message. The truck became noticeably underpowered. When shifted into Reverse, the transmission engaged harshly and the PRNDL (gear position indicator) disappeared from the instrument cluster. The backup camera also became inoperative. After shutting the vehicle off, it would not…

   NHTSA complaint #11745148 · source
8. Filed Jun 17, 2026NCElectrical System

   Horn stopped working. Took to dealer they diagnosed horn pin from bcm to bjb has pulled from wire. Said part to fix has 90 people waiting and indefinite wait time. Or can replace entire wire harness for $1700. After reading on Ford Forum learned this is common problem for truck. In NC horn is mandatory to pass inspection . This is definitely a safety issue

   NHTSA complaint #11744891 · source
9. Filed May 11, 2026TNCrashBody & StructureElectrical SystemEngine

   VEHICLE SAFETY COMPLAINT STATEMENT Prepared for NHTSA Submission Regarding Recall 26V237 / 26S28 To: National Highway Traffic Safety Administration (NHTSA) Subject: Report of Accident and Vehicle Control Loss Due to Defect Specified in Recall 26V237 VEHICLE INFORMATION: Year/Make/Model: 2016 Ford F-150 VIN: [XXX] INCIDENT DESCRIPTION: In March, while driving during a snowstorm, the vehicle experienced a sudden and unexpected loss of traction and stability. Without warning,…

   NHTSA complaint #11736995 · source
10. Filed May 6, 2026LABrakesElectrical SystemTransmission & Drivetrain

    1)Brakes were changed, rotors and pads. Brakes were bled 3 times and it still does not stop correctly. Even when the brakaes are on, it releases itself. 2)Truck keeps shuddering and loosing power. 3Electronics will not stay bluetoothed and it connects and disconnects all by itself all the time. Appears there are recalls on these 3 issues.

    NHTSA complaint #11736016 · source
11. Filed Apr 7, 2026MOElectrical SystemTransmission & Drivetrain

    Saturday 4/4 I took the truck to get a tire repaired. It would not initially start. 5 minutes later it finally did. Then a few blocks away the trucks internal lights started flashing and it jumped from drive into a lower gear. I thought my drive quit working. I pulled over and had reverse and low so I attempted to put in drive, still wouldn't go. After about 5 minutes I was able to get the truck back into drive and get it home where it sits today. I just bought it 1 1/2…

    NHTSA complaint #11729680 · source
12. Filed Apr 7, 2026149,000 miKYElectrical System

    Odometer Fraud. The contact purchased a 2016 Ford F-150. The contact stated that while purchasing a warranty for the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the mileage was 149,000 and at the time of purchasing the warranty, it was discovered that the mileage was 146,000.

    NHTSA complaint #11729652 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology