2019 Ford F-150 electrical system problems

Related recalls

• Recall 19V805000Nov 12, 2019135,725 vehicles
  ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

  Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.

  Risk: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.

  Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.

What owners say

1. Filed Oct 2, 202692,004 miMNBrakesElectrical SystemSteering

   The contact owns a 2019 Ford F-150. The contact stated that after hauling a travel trailer and unhooking the vehicle, the parking brake and other lights started flashing and the instrument panel illuminated. The 911 assist was disabled. A part of the power steering was inoperable. The floorboard was saturated with water, which damaged the wiring harness. The driver was unaware because of the rubber floor mats. A mechanic suggested that the contact disconnect the battery. The…

   NHTSA complaint #11768544 · source
2. Filed Sep 20, 2026MADriver Assistance & Safety TechElectrical SystemTransmission & Drivetrain

   I am writing to formally escalate my ongoing complaint regarding my Ford truck and the repeated problems I have experienced with it over the years. At this point, this is no longer simply a matter of dissatisfaction with a dealership repair. I am asking Ford Motor Company at the corporate level to take responsibility for reviewing the complete history of this vehicle and the repeated unsuccessful attempts to correct the problems I have experienced. Most recently, my truck…

   NHTSA complaint #11765619 · source
3. Filed Jun 26, 2026NJElectrical SystemEngineSteering

   While driving my vehicle (2019 Ford F150), it suddenly came to a complete stop. The engine shut off and the steering wheel locked up. While in the middle of a roadway, I had to quickly throw my vehicle into park, turn it off and back on. At that point, it was running again and I was able to safely get it to a dealership where it was inspected for an issues. There were no warnings, alerts or messages on my dashboard. The dealership confirmed what had happened. It was due to…

   NHTSA complaint #11746712 · source
4. Filed Jun 24, 2026GAElectrical SystemTransmission & Drivetrain

   Our 2019 F150 four-wheel-drive began jerking, hesitating, and gear slipped from 1st to 3rd to 3rd and fifth when we attempted to cross an intersection, our car would not shift at all, and we had to coast across the intersection and it finally caught and began moving forward. The vehicle also displayed a warning light in the dashboard, but it said our trailer was disconnected. We didn’t have a trailerWe brought the vehicle home called the dealership. The next day the vehicle…

   NHTSA complaint #11746329 · source
5. Filed Jun 21, 2026NYAirbagsBody & StructureElectrical System

   I purchased this truck from Don’s Ford, Rt12,Utica,NY in February 2025 didn’t even leave the dealership every light in the dash came on turned around they had my truck for 5 months while I made 6 months of payments, there has been numerous problems since, I took the extended warranty out and was still being charged, I had to change dealer ships because they refused to fix my truck, now there is a recall and there saying I purchased the truck in Canada which I have a bill of…

   NHTSA complaint #11745457 · source
6. Filed May 6, 202692,000 miFLElectrical System

   The contact owns a 2019 Ford F150. The contact stated that the vehicle failed to turn on. The contact opened the hood and noticed smoke emitting from the front. An abnormal burnt wire odor was emitting from the wires. The vehicle was taken to the dealer, where it was diagnosed that the wire harness was burnt and damaged and a fire risk. The vehicle was not repaired due to cost. However, the dealer disconnected the wire harness from the battery due to safety reasons. The…

   NHTSA complaint #11736174 · source
7. Filed Apr 23, 2026TXElectrical SystemOther / Unknown

   I have had 3 complete failures of the door lock actuator motors and a 4th that’s beginning to malfunction on and off. Not only is it an inconvenience for me to lock or unlock my vehicle by key fob or utilizing internal control switches It is very unsafe that vehicle will not automatically lock when put into drive.

   NHTSA complaint #11733438 · source
8. Filed Apr 3, 2026FLElectrical SystemEngineOther / Unknown

   It seems when the truck has been driven more than an a half hour to an hour and you shut the truck off the truck won't start back up. I believe the starter gets what they call heat soaked, then you have to wait until the truck cools down then I will start normal

   NHTSA complaint #11729083 · source
9. Filed Mar 30, 2026ILFireElectrical SystemEngine

   While driving on the highway on 02/20/2026 at approximately 152,000 miles, my 2019 Ford F-150 3.0L Power Stroke diesel caught fire and was completely destroyed. The day before the fire (02/19/2026), the FordPass app logged an electrical system error that self-cleared the same day. Believing the issue resolved itself, I continued normal operation. The following day the vehicle caught fire on the highway and was a total loss. Ford's own telematics system captured the fault…

   NHTSA complaint #11727952 · source
10. Filed Mar 11, 2026GAElectrical SystemEngineTransmission & Drivetrain

    You can smell something getting hot the gauges jump everywhere and the 12 volt outlet constantly flashes red or orange. The screen goes out for long periods of time and the transmission shifts down so hard and then misses gears shifting up causing the person driving to lose momentum. I can not believe this truck has not been recalled yet. It’s been at the dealers shop 20 times for electrical issues. They knew it was a lemon and still sold it to us. I hope y’all do the right…

    NHTSA complaint #11723649 · source
11. Filed Feb 26, 2026VAElectrical System

    Bought truck from Carvanna with a open recall. Backup camera listed on description as couldn't remedy and also pictures of it not working. Took to friendship Ford for major repairs and asked them to fix recall. Wouldn't fix back up camera cause couldn't get to duplicate. Contacted my case worker corrina at carvanna executive resolution team told her they wouldn't fix the recall also sent her a video of the back up camera not working she responded by she couldn't make Ford do…

    NHTSA complaint #11720591 · source
12. Filed Feb 20, 2026NMElectrical SystemEngine

    My 2019 Ford F-150 (2.7L EcoBoost) is subject to Emission Recall 24E12, which addresses a defective PCM calibration that Ford acknowledges "could, over time, reduce the effectiveness of the emissions control system and the monitoring accuracy of the catalytic converter's efficiency." COMPONENT: Catalytic converter system and powertrain control module (PCM). Vehicle is available for inspection at Rich Ford in Albuquerque, NM, where it has been serviced for this issue.…

    NHTSA complaint #11719515 · source

Source: U.S. National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation public data. Complaints are submitted by owners and are not verified by NHTSA or by us; a complaint does not prove a defect exists. View this vehicle on NHTSA.gov Methodology